Lincoln Electric CAN-CW800-C Datasheet

M A T E R I A L S A F E T Y D A T A S H E E T
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed. All ingredients listed may not be present in all sizes.
(1) The term "hazardous" in "Hazardous Ingredients" should be interpreted as a term required and defined in the Hazardous Products Act and does not
necessarily imply the existence of any hazard.
Ingredients:
Chromium and chromium alloys or compounds (as Cr)
Iron
Nickel (metal)
Titanium dioxides (as Ti)
Zirconium alloys and compounds (as Zr)
Molybdenum alloys (as Mo)
Manganese and/or manganese alloys and compounds (as Mn)
Silicates and other binders
Quartz
Aluminum and/or aluminum alloys (as Al)
Fluorides (as F)
Complex compounds
Titanium and/or titanium alloys (as Ti)
Silicon and/or silicon alloys and compounds (as Si)
Alkali carbonates
Stainless steel tube
Nominal tube composition:
Chromium
Nickel
Manganese
Iron
Notes:
(*) Not listed. Nuisance value maximum is 10 milligrams per cubic
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(**) As respirable dust.
(***) These compounds contain oxides of Si, K. The lowest TLV is 5 for
those metals and oxides having a TLV listing and 10 milligrams
per cubic meter for those not listed.
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable to
this product and its use.
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in
Section VIII. Product is inert, no special handling or spill procedures required.
Rev 11/06b
For Welding Consumables and Related Products
Section I & II - Preparation and Product Information
Section III - Hazardous Ingredients (1)
Section IV - Physical Data
Section V - Hazard Data
Date:
11/15/06
Trade Name:
Blue Max Flux Cored Stainless Electrodes
Sizes: All
Supersedes: 1/5/04
Flux Cored Electrode
Product Type:
Blue Max
Products:
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
TLV
CAS No. Wt. % mg/m
7440-47-3 5-10 0.5(b)
7439-89-6 5-10
7440-02-0 1-5
13463-67-7 1-5
12004-83-0 1-5
7439-98-7 1-5
7439-96-5 1-5
1344-09-8 1-5
14808-60-7 0.1-1 #0.05**
7429-90-5 0.1-1
7789-75-5 0.1-1
66402-68-4 0.1-1
12719-90-3 0.1-1
7440-21-3 0.1-1
584-08-7 0.1-1
60-100
7440-47-3 19 0.5(b)
7440-02-0 10
7439-96-5 1.5
7439-89-6 bal.
(LDLo, LCLo) Lowest published toxic concentration.
(b) The OSHA PEL for chromium (VI) is 5 micrograms (0.005
milligrams) per cubic meter. The TLV for water soluble
chromium (VI) is 0.05 milligrams per cubic meter and the
TLV for insoluble chromium (VI) is 0.01 milligrams per
cubic meter.
(#) Crystalline silica (quartz) is on the IARC (International
Agency for Research on Cancer) and NTP (National
Toxicology Program) lists as posing a carcinogenic risk to
humans.
MSDS No.:
CAN-CW800-C
FC-308L, FC-309L, FC316L,
FCP 309L, FCP316L
LD
50
3
(Route/Species)
2.16 mg/kg LDLo
(intravenous/rat)tumorigenic
10*
Not Available
50 mg/kg LDLo
1.5
(intravenous/mouse)
10
Not Available
5
Not Available
114 mg/kg LDLo
10
(intraperitoneal/rat)
9 g/kg
0.2
(oral/rat)
1153 mg/kg
10*
(oral/rat)
200 mg/kg LDLo
(intratracheal/rat)
10
Not Available
4250 mg/kg
2.5
(oral/rat)
***
Not Available
114 mg/kg LDLo
10*
(intramuscular/rat)
10*
Not Available
1870 mg/kg
10*
(oral/rat)
2.16 mg/kg LDLo
(intravenous/rat)tumorigenic
50 mg/kg LDLo
1.5
(intravenous/mouse)
9 g/kg
0.2
(oral/rat)
10*
Not Available
(CONTINUED ON SIDE TWO)
3
LC mg/m
50
(Route/Species)
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
2.3 LCLo
(inhalation/human)
Not Available
300 LCLo
(inhalation/human)
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
2.3 LCLo
(inhalation/human)
Not Available