Freewheeling; Main Circuit Breaker - Eagle LIBERTYTM 624 Owner's Manual

Eagle mini-powerchair owner's manual libertytm 624
Table of Contents

Advertisement

10
Green
9
Green
8
Green
7
Yellow
6
Yellow
Connections
5
Yellow
4
Yellow
3
Red
2
Red
1
Red
For convenience, your LIBERTY™ 624 MINI is equipped with two freewheel levers. These levers
allow you to disengage the drive motors and maneuver the chair manually. Locate the 2 metal bars
protruding from the frame cover and turn them toward the outside of the powerchair. To reengage
the drive motors, turn the metal levers back to the forward position. If the lever is difficult to move
in either direction, press the lever downward and roll the LIBERTY™ 624 MINI forward and
backward slightly. The lever should then move to the desired position.
Eagle Note: It is important to remember that when the LIBERTY™ 624 MINI is in the freewheel
position, the braking system is disengaged.
WARNING: Avoid placing the LIBERTY™ 624 MINI in freewheel on an incline as the unit could
roll on its own causing injury.
The circuit breaker is located under the main body cover on the left rear side of the frame.
The main circuit breaker is a safety feature built into your LIBERTY™ 624 MINI. When the
batteries and the motors are subjected to excessive loads, the main circuit breaker might trip
to prevent damage to the motors and/or electronics. If this happens, allow the unit to rest for
approximately one minute, to allow time for the automatic rest circuit breaker to reset. You may
wish to charge the batteries more frequently and have an authorized service center or service station
load test the batteries to determine how they operate under normal operation.
Eagle Note: If the main circuit breaker continues to trip, you should return to your authorized
LIBERTY™ 624 MINI dealer for service.
BARS DIAGNOSIS SOLUTION
High Battery Voltage
Solenoid Brake Fault
Possible Controller Fault
Possible Joystick Fault
Inhibit Active
Right Motor Wiring Fault Check
Right Motor Disconnected
Left Motor Wiring Fault
Left Motor Disconnected
Low Battery Voltage

Freewheeling

Main Circuit Breaker

13
Check Batteries
Check Motor/Brake Wiring
See Authorized Service Center
See Authorized Service Center
Unplug Charger/Check
Right Motor Wiring
Check Right Motor Wiring
Check Left Motor Wiring
Check Left Motor Wiring
Check Batteries/Battery Wiring

Advertisement

Table of Contents
loading

This manual is also suitable for:

Liberty 624mini

Table of Contents