Table of Contents
Advertisement
Quick Links
For more information, visit www.desatech.com
Models: PHK-18/24/30; BCS18/24/30
WARNING: If the information in this manual is not fol-
lowed exactly, a fi re or explosion may result causing
property damage, personal injury, or loss of life.
— Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call the
fi re department.
— Installation and service must be performed by
a qualifi ed installer, service agency, or the gas
supplier.
WARNING: This is a gas-fi red appliance. It uses air (oxygen) from the room in which it is in-
stalled. Provisions for adequate combustion and ventilation air must be provided. Refer to
the National Fuel Gas Codes, ANSI Z233.1/NFPA 54, Section 5.3, Air for Combustion and Ven-
tilation.
This appliance may be installed in an aftermarket,* permanently located, manufactured (mo-
bile) home, where not prohibited by local codes.
* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer
VENTED DECORATIVE NATURAL GAS LOGS
OWNER'S OPERATION AND
INSTALLATION MANUAL
Save this manual for future reference
TESTED AND
LISTED BY
RGA 2-72 Approved
WARNING: Improper installation,
adjustment, alteration, service,
or maintenance can cause injury
or property damage. Refer to this
manual for correct installation and
operational procedures. For as-
sistance or additional information
consult a qualifi ed installer, service
agency, or the gas supplier.
WARNING: This appliance is for
installation only in a solid-fuel burn-
ing masonry or UL127 factory-built
fi replace, constructed of noncom-
bustible material, and connected
to a working fl ue. (See page 7 for
minimum fl ue opening.)
Advertisement
Table of Contents
Related Manuals for Desa BCS18, BCS24, BCS30
Summary of Contents for Desa BCS18, BCS24, BCS30
- Page 1 VENTED DECORATIVE NATURAL GAS LOGS For more information, visit www.desatech.com Models: PHK-18/24/30; BCS18/24/30 WARNING: If the information in this manual is not fol- lowed exactly, a fi re or explosion may result causing property damage, personal injury, or loss of life. —...
-
Page 2: Table Of Contents
TABLE OF CONTENTS SAFETY INFORMATION TABLE OF CONTENTS SAFETY INFORMATION ...2 PRODUCT IDENTIFICATION ...3 LOCAL CODES ...3 UNPACKING ...3 INSTALLATION ...4 OPERATING APPLIANCE ...8 CLEANING AND MAINTENANCE ...8 SERVICE HINTS ...8 SAFETY INFORMATION WARNINGS WARNING: This product contains and/or generates chemicals known to the State of California to cause cancer or birth defects, or other reproductive harm. -
Page 3: Product Identification
SAFETY INFORMATION Continued 10. The installation and provisions for combustion and ventilation air must conform with the National Fuel Gas Code, ANSI Z233.1/ NFPA 54, Section 5.3, Air for Combustion and Ventilation. 11. Do not run log set • where fl ammable liquids or vapors are used or stored •... -
Page 4: Installation
INSTALLATION Flue Opening Specifi cations Check Gas Type Venting Specifi cations for Installation INSTALLATION CAUTION: Do not remove the data plates attached to the burner pan. The data plates contain important warranty information. WARNING: Before installing in a solid fuel burning fi... -
Page 5: Connecting To Gas Supply
INSTALLATION Continued INSTALLING DAMPER CLAMP Secure the damper stop clamp provided to the leading edge of the damper as shown in Figure 3. If for any reason this clamp doesn't work on your fi replace, another suitable clamp or permanent stop must be installed, or the damper blade must be cut or removed. -
Page 6: Checking Gas Connections
INSTALLATION Checking Gas Connections Hearth Kit Assembly and Installation INSTALLATION Continued CHECKING GAS CONNECTIONS WARNING: Test all gas piping and connections, internal and external to unit, for leaks after installing or servicing. Correct all leaks at once. WARNING: Never use an open fl ame to check for a leak. -
Page 7: Testing Burner For Leaks
INSTALLATION Continued TESTING BURNER FOR LEAKS Generously apply noncorrosive leak detection fl uid to all connections. WARNING: Never check for gas leaks with open fl ame. Light the burner with the shutoff valve no more than half open and holding a match slightly in front of the pan (see Lighting Instructions, page 10). -
Page 8: Operating Appliance
If so, contact DESA’s Technical Service Depart- to close, as ment at 1-866-672-6040. When calling please have your model and serial numbers of your heater ready. You can also visit DESA’s technical services web site at www. desatech.com. to the OFF position. CURING... -
Page 9: Troubleshooting
SERVICE HINTS TROUBLESHOOTING SERVICE HINTS When Gas Pressure is Too Low • pilot will not stay lit • burners will have delayed ignition • heater will not produce specifi ed heat • propane/LP gas supply may be low You may feel your gas pressure is too low. If so, contact your local propane/LP or natural gas supplier. - Page 10 TROUBLESHOOTING TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Fol- low the gas supplier’s instructions.
-
Page 11: Accessories
ACCESSORIES Purchase these log set accessories from your local dealer. If they can not supply these accessories, call DESA at 1-866-672-6040 for referral information. You can also write to the address listed on the back page of this manual. EQUIPMENT SHUTOFF VALVE - GA5010 For all models. -
Page 12: Illustrated Parts Breakdown
ILLUSTRATED PARTS BREAKDOWN Models: PHK-18/24/30; BCS18/24/30 ILLUSTRATED PARTS BREAKDOWN Models: PHK-18/24/30; BCS18/24/30 ( Number and style of logs vary by model ) For more information, visit www.desatech.com 115425-01... -
Page 13: Parts List
PARTS LIST This list contains replaceable parts used in your log set. When ordering parts, follow the instructions listed under Replacement Parts on page 12 of this manual. Key No. Part Number PHK/BCS 18 PHK/BCS 24 1 14325 14325 2 901059-01 901059-01 3 901232-01 901232-01... -
Page 14: Owner's Registration Form
Address: City: Home Phone: E-Mail: Please answer the following questions to register your product with DESA: Where will the product be used? m Living/Family Room ❍ Office/Warehouse If you bought this product yourself, did you plan to purchase this type of product before going into the store? Who selected the product? ❍... - Page 15 For more information, visit www.desatech.com 115425-01 TAPE 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 TAPE Postage Required...
-
Page 16: Warranty Information
LIMITED WARRANTY - VENTED GAS LOGS DESA warrants this product to be free from defects for a lifetime, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. To make a claim under this warranty the Bill of Sale or cancelled check must be presented.