Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes.
The openings should never be blocked by placing the product on a bed, sofa, rug, or other similar surface. This product should never be placed near or over a radiator or heat register. This product should not be placed in a built-in installation unless proper ventilation is provided. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
4.6 Show “No Signal” on screen ....................45 4.7 Keypad can not work......................45 5.Adjust Procedure ..................46 5.1 PREPARATION OF MANUAL ALIGNMENT..............47 5.2 COLOR TEMPERATURE ALIGNMENT ................48 5.3 FACTORY PRESET SETTING..................50 6.Mechanical Assembly ................51 ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 5
6.2 Mechnical Parts List ......................56 7.Schematic Diagrams .................. 57 8.PCB Layout ....................64 9.Parts Lists....................67 9.1 Recommended Spare Parts List ..................67 9.2 Complete Parts List ......................69 ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
2.3.1 RGB Video Signals 2.3.1.1 Separate Sync. Signals Analog R, G, B 0 - 0.7 Vp-p Signal Level 75 ± 5% Sync Level TTL level Sync Polarity independent 2.3.1.2 Sync On green, Composite Sync ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 9
4 Ohm Output Wattage 3.0W (max.) x 2 2.3.4 Input Signal Connectors 2.3.4.1 Analog RGB Video Input: 15 pin mini D-sub PIN NO. Separate Sync GREEN BLUE GROUND GROUND GROUND GROUND GROUND GROUND ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 11
60.02 ±1.0Hz 1280X1024(60) VESA STANDARD MOD [21] 79.976 ±1.0KHz 75.0 ±1.0Hz 1280X1024(75) VESA STANDARD 2.4 Luminance Control Analog signal (6500K) Over 200 cd / m (@ Cont / Bright max) Digital signal (6500K) ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 12
These characteristics were measured under the following conditions: Temperature: 77 ± 6°F, 25 ± 5°C Viewing angle: AU = 0°, AR = 0° Warm Up time: minimum 30 minutes Measuring instrument: TOPCOM BM-7 Luminance Meter Measuring distance: 500 mm ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 13
(Note 2) Viewing angle is measured as follows: ’ ’ (Note 3) Definition of response time is as follows: Response time is measured when the display data is changed from white to black. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 14
White(TFT OFF) White Optical Response (Note 4) Judge points for brightness uniformity Brightness uniformity is judged at nine (9) points on display area: Bmin BUNI Bmax Bmax: Maximum Brightness Bmin : Minimum Brightness ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 15
Typical Tr = 15ms ; Tf = 10ms Maximum Tr = 20ms; Tf = 15ms Number of Back Light(CECIL) 6 – Edge type back light Backlight (hrs) 50,000 hours minimum; 60,000 hours typical ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Paste on Rear Back Label Contents: Appendix III 3.5 Serial Number Format Serial No. PPP YY WW XXXXX Serial No. (5-digit) Manufacturing week Last digit of manufacturing year Regional Product ID Code: VX800-3:A28 ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
6.1 OSD Brightness 100% (based on 0-100%) Contrast 80% (based on 0-100%) AutoTune Executed Color Temperature 6500k Volume Balance Bass/Treble OSD Timeout 15 Sec Language English OSD position Center 6.2 Power Switch ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Appendix I Preset Signal Timings H-Video H active Horizontal H front H back H pulse H total V-Video V active Vertical V front V back V pulse V total ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
V L CD S 26105-1 S e r i a l N u m b e r : A28YYWWnnnnn 7 66907 81271 8 MODEL NUMBER: VLCDS26105-1W SERIAL NUMBER: A28YYWWnnnnn Made In China ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
4. Press ‘1” button will enter OSD main menu. 5. Press “volume plus”, “volume minus” can directly adjust the audio volume. 6. Press “mute” button can directly mute on or off the audio volume. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
(See computer or graphic card user guide to adjust refresh rate.) The panel may be manually tuned using the horizontal and vertical phase controls shown below. Contrasts adjust foreground white level of screen image. [ ] increase contrast, [ ] decease contrast. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 28
Audio press [ ] or [ ] button to scroll desired menu option. Press [2] button to select submenu option. Audio Volume Balance Bass Treble Mute 1 : Exit 2 : Select ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 29
Bass/Treble adjusts the high (treble) and low (bass) frequency audio output Press [2] button to select bass adjustment. Bass press [ ] or [ ] to adjust bass. Treble press [ ] or [ ] to adjust treble. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 30
1 To adjust selected color, press [ ] or [ ]. 2 Press button [2] to set adjustment and select next color to adjust. User Color Green Blue 1 : Exit 2 : Select ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 31
Press the [2] button to toggle between H. or V. Position. V-Position moves screen image up or down. [ ] move screen image down , [ ] moves screen image up . ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Sharpness adjusts the clarity of a non-SXGA (1280 x 1024) RGB signal Press [ ] or [ ] to adjust. Setup Menu Setup Menu Language Resolution Notice OSD Position OSD Timeout OSD Background Touch Tone 1 : Exit 2 : Select ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 33
: E xit : S elect OSD Position press the [2] button to select the OSD H-Position or OSD V-Position. OSD H-Position [ ] moves OSD left; [ ] moves the OSD right. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 34
OSD V-Position [ ] moves OSD down; [ ] moves the OSD up. OSD Timeout sets the length of time the Onscreen Display screen is displayed before exiting. OSD Background ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 35
H/V Position, Color Temperature @ 6500K, OSD Position, Sharpness, & OSD Timeout. OSD Auto Save The OSD shall save new settings when it is turned off by the user or when it times out. There shall not be a separate save. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Pin 40 controls the brightness of panel Pin 41, 42 controls LED (orange and green) on /off Pin 123 control audio boards 12V on/off Pin 126 control IC500, IC501 (LVDS Transmitter) on/off. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 38
XTAL can be driven by a single-ended TTL/CMOS input clock (e.g. for testing of the IC) – the TCLK pin should be grounded through a 2.7k pull down resistor to maintain the correct duty cycle for the clock. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 39
(LVDS) line drivers in a single integrated circuit. These functions allow 28 bits of single-ended low-voltage TTL (LVTTL) data to be synchronously transmitted over five balanced-pair conductors for receipt by a compatible receiver, ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 40
(SHTDN) active-low input to inhibit the clock and shut off the LVDS output drivers for lower power consumption. A low-level signal on SHTDN clears all internal registers to a low level. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Lin 3 Light channel input 3 Lin 2 Light channel input 2 Lin 1 Light channel input 1 Audio processor left channel input Lout Gain output and input selector for left channel ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 42
Pins 1 and 9 are right and left channel inputs respectively. Pins 4 and 6 are right and left channel outputs which connect to two 8 OHM speakers. Pin 8 is the mute/stand-by Pin 7 is the voltage input for ICA1 ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 45
FIG 13. LVDS TX0+ FIG 14. LVDS TX0- FIG 15. LVDS CLOCK+ FIG 16. LVDS CLOCK- FIG 17. AUDIO SINE SIGNAL IN FIG 18. AUDIO SINE SIGNAL OUT ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Check that the voltage level of CN100 is approximately 12V Check Check CN301 pin1 IC100 failure FB100, FB101 F100 or power board failure is12V, pin5 is 5V failure Inverter failure Check IC400 Pin 114 failures ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
2. Disconnected between CN100 and power board Check that FB100, FB101 Failure point Is 12V F100 failure Check that IC100 Failure point pin 2 is about 5V FB100, FB101 failure Failure point 1.L200 failure 2.D200 failure 3.IC100 failure ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Factory VX800-3 01/10 / 2003 Color Temp Factory Default Brightness Blacklevel AutoColor Initial EDID CopyColorTemp Gamma Otherwise, follow the procedure described in session 1.4.1 to enter the factory mode again ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Before manually adjusting color temperature, set OSD contrast 80%, brightness 100% (factory default), enter into factory mode and select “color temp. manual” item 2.1 9300°k alignment 2.1.1 use “up” or “down” key to move cursor to 9300 color ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 54
Then press “2” key to select 5400 color temperature adjustment. 2.3.2 Use “2” to move cursor to r-driver or g-driver or b-driver and then press “up” or “down” key to adjust it to meet ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
The above result R, G, B gain will automatically be saved, when exiting the factory Mode OSD menu. 5.3 Factory Preset Setting 3.1 in factory mode OSD main menu select factory default setting. Press “2” to confirm the selection. ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
CONN DVI-D M-MS-0808-4686 3200462800 NAME PLATE AL+PC VSC 3-BIRD LO M-MS-0808-8151 3200641801 NAME PLATE AL 43*6.9*1.15T VIE M-MS-0808-7739 3200648800 NAME PLATE ABS 94HB VIEWSONIC M-LB-0813-0763 3201942500 LABEL ID 160*43 VSC VX800-3 M-LB-0813-0700 3202207300 LABEL MIC IN 10.2*15 M-LB-0813-0714 3202310700 LABEL HV WARNING 100*25...
9.2 Complete Parts List VS Model Name: VX800-3 ITEM VIEWSONIC P/N REFERENCE NO. MFG PART DESCRIPTION QTY UM POWER 90-264VAC 12VDC 5A 1 A-AD-0114-0182 0993026502 ADP-60AF A 1 PCE AC POWER CORD L1800 BLACK 2 A-PC-0106-0193 3070000501 WP201-WTP-003 1 PCE...
Page 75
113 M-LCD-0826-0127 3510552100 0.1 PCE ANGLE PAPER 2190*55*55 3510807600 0.1 PCE CAP PAPER 1140*1050*120 3510878400 0 PCE CARTON 565*265*595 VSC VG800-2 116 P-BX-0601-0784 3512234900 1 PCE PALLET FUMIGATED 1070*1140*120 3520026000 0 PCE ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 76
UUT1E100MCR1GS 1 PCE CAP AL CP 25V 10U M 5*5.7 176 E-C-0404-4859 149141001203 UUT1E100MCR1GS 1 PCE 177 E-C-0404-4879 1511477000 2238 586 15528 CAP MC CP 50V 2.7KP J X7R 0603 1 PCE ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 79
CAP AL CP 16V 47U M 6.3*5.5 148124701308 16REV47M6.3*5.5 1 PCE CAP AL CP 16V 10U M 4*5.5 149121001108 16RGV10M4*5.5 1 PCE 149121001133 UWT1C100MCR1GB CAP AL CP 16V 10U M 4*5.4 1 PCE ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 80
CAP MC CP 25V .1U K X7R 0603 1552458000 C0603X104K025T 1 PCE CAP MC CP 25V .1U K X7R 0603 1552458000 C0603X104K025T 1 PCE 1552458000 C0603X104K025T CAP MC CP 25V .1U K X7R 0603 1 PCE ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
Page 81
DIO SW 0.215A 75V SOT-23 SE. 475 E-D-0403-2050 204520700207 BAV99,235 1 PCE DIO SW 0.215A 75V SOT-23 SE. 476 E-D-0403-2050 204520700207 BAV99,235 1 PCE 477 E-D-0403-2050 204520700207 BAV99,235 DIO SW 0.215A 75V SOT-23 SE. 1 PCE ViewSonic Corporation VX800-3 Confidential – Do Not Copy...
*Readers Response* Dear Readers: Thank you in advance for your feedback on our Service Manual,which allows continuous improvement of our products. We would appreciate your completion of the Assessment Matrix below, for return to ViewSonic corporation Assessment A. What do you think about the content after reading...