Page 3 This section tells you when to perform vehicle maintenance and what fluids and lubricants to use............Customer Assistance Information This section tells you how to contact Chevrolet/Geo for assistance and how to get service publications. also gives you information on “Reporting Safety Defects” on page 8-4.
Page 4 We support voluntary technician certification. GENERAL MOTORS, GM and the GM Emblem, SUPPORT CHEVROLET and the Chevrolet Emblem, Geo and the VOLUNTARY TECHNICIAN CERTIFICATION THROUGH Geo Emblem are registered trademarks of General Natlonal lnslltute for Motors Corporation. A U T O M O T I V E...
Page 5 How to Use This Manual Many people read their owner’s manual from beginning to end when they first receive their new vehicle. This will help learn about the features and controls for your vehicle. In this manual, you’ll find that pictures and words work together to explain things quickly.
Page 6 Vehicle Damage Warnings In the notice area, we tell you about something that can damage your vehicle. Many times, this damage would Also, in this book you will find these notices: not be covered by your warranty, and it could be costly. But the notice will tell you what to do to help avoid the damage.
Page 7 These symbols Here are some Vehicle Symbols are used on other symbols These are some of the symbols you may find on your vehicle. warning and you may see: indicator lights: For example, These symbols These symbols These symbols FUSE these symbols are important have to do with...
Page 8 NOTES...
Page 9 P Section 1 Seats and Restraint Systems Here you’ll find information about the seats in your Geo and how to use your safety belts properly. You can also learn about some things you should do with air bags and safety belts. Seats and Seat Controls This section tells you about the seats -- how to adjust them, and also about reclining front seatbacks, head...
Page 10 Reclining Front Seatbacks To adjust the seatback, lift the lever on the outer side the seat. Release the lever to lock the seatback where you want it. Push on the seat to make sure it's locked in position. Pull up on the lever, and the seat will eo to its But don't have a seatback reclined if your vehicle is orieinal upright position.
Page 11 Head Restraints Slide the head restraint up or down so that the top of the restraint is closest to the top of your ears. This position reduces the chance of a neck injury in a crash. Pull up to raise the restraint. lower it, push the release button and push down.
Page 12 Rear Folding Seatback (Option) You can fold either side of the seatback down in your Geo for more cargo space. To fold either seatback down: 1. Make sure the front seat isn’t reclined. If it is, the rear seatback won’t fold down all the way. 2.
Page 13 Safety Belts: They’re for Everyone Your vehicle has a light that comes on as This part of the manual tells you how to use safety belts a reminder to buckle properly. It also tells you some things you should not do up.
Page 14 Why Safety Belts Work When you ride in or on anything, you go as fast as it goes. Put someone on it. Take the simplest vehicle. Suppose it's just a seat on wheels.
Page 15 Get it up to speed. Then stop the vehicle. The rider The person keeps going until stopped by something. doesn’t stop. In a real vehicle, it could be the windshield...
Page 16 or the instrument panel or the safety belts! With safety belts, you slow down as the vehicle does. You get more time to stop. You stop over more distance, and your strongest bones take the forces. That's why safety belts make such good sense.
Page 17 Q.” Here Are Questions Many People Ask If I’m a good driver, and I never drive far from home, why should I wear safety belts? About Safety Belts -- and the Answers You may be an excellent driver, but if you’re in an Won’t I be trapped in the vehicle after an your accident...
Page 18 Driver Position How to Wear Safety Belts Properly This part describes the driver’s restraint system. Adults Lap-Shoulder Belt This part is only for people of adult size. The driver has a lap-shoulder belt. Here’s how to wear Be aware that there are special things to know about safety belts and children.
Page 19 Pull up on the latch plate to make sure it is secure. If the belt isn’t long enough, see “Safety Belt Extender’’ at the end of this section. Make sure the release button on the buckle is positioned so you would be able to unbuckle the safety belt quickly if you ever had to.
Page 20 The lap part of the belt should be worn low and snug on the hips, just touching the thighs. In a crash, this applies force to the strong pelvic bones. And you’d be less likely to slide under the lap belt. If you slid under it, the belt would apply force at your abdomen.
Page 21 Shoulder Belt Height Adjuster Pull the release knob and move the height adjuster to the desired position. When you release the knob, try to Before you begin to drive, move the shoulder belt move the adjuster down to make sure it has locked into adjuster to the height that is right for you.
Page 22 What’s wrong with this? The shoulder belt is too loose. It won’t give nearly as much protection this way. 1-14...
Page 23 What's wrong with this? The belt is buckled in the wrong place.
Page 24 What's wrong with this? The shoulder belt is worn under the arm. It should be worn over the shoulder at all times. 1-16...
Page 25 What’s wrong with this? The belt is twisted across the body.
Page 26 This part explains the Supplemental Restraint System To unlatch the belt, just push the button on the buckle. (SRS), or air bag system. The belt should go back out of the way. Supplemental Restraint System (SRS) Your Geo has two air bags one air bag for the driver and another air bag for the right front passenger.
Page 27 There is an air bag readiness light on the instrument panel, which shows AI R AIR BAG on it. The system checks the air bag’s electrical system for malfunctions. The light tells you if there is an electric4 Problem. See “Air Bag Readiness Light’’ in the Index for more information.
Page 28 How the Air Bag System Works Where is the air bag? The driver's air bag is in the middle of the steering wheel. The right front passenger's air bag is in the instrument panel on the passenger's side. 1-20...
Page 29 a parked car, the threshold level will be higher. The air bag is not designed to inflate rollovers, side impacts, rear impacts, because inflation would not help the occupant. crash only one of the two air bags It is possible that in Pnzm in your will deploy.
Page 30 How does an air bag restrain? In moderate to severe frontal or near-frontal collisions, even belted occupants can contact the steering wheel or the instrument panel. The air bag supplements the protection provided by safety belts. Air bags distribute the force of the impact more evenly over the occupant’s upper body, stopping the occupant more gradually.
Page 31 Your Let only qualified technicians work your air bag Chevrolet/Geo dealer and the 1995 Prizm Service system. Improper service can mean that your Manual have information about servicing your vehicle system won’t work properly. See your dealer for and the air bag system.
Page 32 The best way to protect the fetus is to protect the Safety Belt Use During Pregnancy mother. When safety belt is worn properly, it’s more Safety belts work for everyone, including pregnant likely that the fetus won’t be hurt in a crash. For women.
Page 33 Rear Seat Outside Passenger Positions Lap-Shoulder Belt The positions next to the windows have lap-shoulder belts. Here’s how to wear one properly. Pick up the latch plate and pull the belt across you. Don’t let it get twisted. The shoulder belt may lock if you pull the belt across you very quickly.
Page 34 When the shoulder belt is pulled out all the way, it will lock. If it does, let it go back all the way and start again. If the belt is not long enough, see “Safety Belt Extender” at the end of this section. Make sure the release button on the buckle is positioned so you would be able to unbuckle the safety belt quickly if you ever had to.
Page 35 The safety belt locks if there’s a sudden stop or a crash, or if pull the belt very quickly out of the retractor To unlatch the belt, just push the button on the buckle.
Page 36 Center Passenger Position Lap Belt If your vehicle has a rear bench seat, someone can sit in the center position. When you sit in the center seating position, you have a lap safety belt, which has no retractor. To make the belt longer, tilt the latch plate and pull it along the belt.
Page 37 Children Everyone in a vehicle needs protection! That includes infants all children smaller than adult size. In fact, the law in every state in the United States and in every Canadian province says children up to some age must be restrained while in vehicle.
Page 39 Child Restraints Be sure to follow the instructions for the restraint. You may find these instructions on the restraint itself or in a booklet, or both. These restraints use the belt system in your vehicle, but the child also has to be secured within the restraint to help reduce the chance of personal injury.
Page 40 If you need to have an anchor installed, you can ask your Chevrolet/Geo dealer to put it in for you. If 1. Put the restraint on the seat. Follow the instructions you want to install an anchor yourself, your dealer can for the child restraint.
Page 41 Pick up the latch plate, and run the lap and shoulder 5. Pull the rest of the shoulder belt all the way out of portions of the vehicle’s safety belt through or the retractor to set the lock. around the restraint. The child restraint instructions will show you how.
Page 42 Securing a Child Restraint in the Center 6. To tighten the belt, feed the shoulder belt into the retractor while you push down the child restraint. Rear Seat Position You’ll be using the lap belt. See the earlier part about the top strap if the child restraint has one.
Page 43 1. Make the belt as long as possible by tilting the latch plate and pulling it along the belt. Put the restraint on the seat. Follow the instructions 5. Buckle the belt. Make sure the release button is for the child restraint. positioned so you would be able to unbuckle the Secure the child in the child restraint as the safety belt quickly if you ever had to.
Page 44 6. To Securing a Child Restraint in the Right tighten the belt, pull its free end while you push down on the child restraint. Front Seat Position 7. Push and pull the child restraint in different directions to be sure it is secure. If the child restraint isn’t secure, turn the latch plate over and buckle it again.
Page 45 You’ll be using the lap-shoulder belt. See the earlier part about the top strap if the child restraint has one. 1. Because your vehicle has a right front passenger air bag, always move the seat as far back as it will go before securing a forward-facing child restraint.
Page 46 6. Pull the rest of the shoulder belt all the way out of the retractor to set the lock. 7. To tighten the belt, feed the shoulder belt back into the retractor while you push down on the child restraint. 8.
Page 47 If you have the choice, a child should sit next to a Larger Children window so the child can wear a lap-shoulder belt and get the additional restraint a shoulder belt can provide. Accident statistics show that children are safer if they are restrained in the rear seat.
Page 48 What if a child is wearing a lap-shoulder belt, but the child is so small that the shoulder belt is very close to the child’s face or neck? Move the child toward the center of the vehicle, but be sure that the shoulder belt still is on the child’s shoulder, so that in a crash the child’s upper body would have the restraint that belts provide.
Page 49 Wherever the child sits, the lap portion of the belt should be worn low and snug on the hips, just touching the child’s thighs. This applies belt force to the child’s pelvic bones in a crash. Belt Extender Safety If the vehicle’s safety belt will fasten around you, you should use But if a safety belt isn’t long enough to fasten, your dealer will order you an extender.
Page 50 If you ever see a label on the driver’s or the right front you choose. Don’t let someone else use it, and use it passenger’s safety belt that says to replace the belt, be only for the seat it is made to fit. To wear it, just attach it sure to do so.
Page 51 G E G B Section 2 Features and Controls Here you can learn about the many standard and optional features on your Geo, and information on starting, shifting and braking. Also explained are the instrument panel and the warning systems that tell you everything is working properly and what to do if you have a problem.
Page 52 One key is used for the NOTICE: ignition, the doors, and all Your Geo has a number of features that can help prevent theft. But you can have a lot of trouble getting into your vehicle if you ever lock your keys inside.
Page 53 Door Locks There are several ways to lock and unlock your vehicle: From the outside, use your key. To lock the door, turn the top of the key toward the front of the car. If you have power door locks, all the doors will lock. Insert the key in any front door and turn the top of the key toward the rear of the car unlock the door.
Page 54 Power Door Locks (Option) lock the door from the inside, push down the button on the door. unlock the door, pull up on the button. Push the power door lock switch on the driver’s door to lock or unlock all the doors at once. Leaving Your Vehicle If you are leaving the vehicle, take your key, open your door and set the locks from inside.
Page 55 Rear Door Security Locks If you want to open a rear door when the security lock is Your Geo is equipped with rear door security locks that help prevent passengers from opening the rear doors of 1. Unlock the door from the inside. your car from the inside.
Page 56 Trunk Lock Release To open the trunk lid, use your key and turn it clockwise. To close the lid, lower and press down on it. After closing the lid, try pulling it up to make sure it is closed. If you don’t cancel the security lock feature, adults and older children who ride in the rear won’t be able to open the rear door from the inside.
Page 57 Remote Trunk Lock Release Storage and Compartments Pull the lever on the floor Cupholder near the driver's door to open the trunk lid from inside your vehicle. To open the cupholder, push and release the bar and the cupholder will slide out. With cups removed, push it back in to store.
Page 58 Glove Box Console Storage Area A small storage area is the console between the seats. If there is a cover, lift to access the storage area. Door Storage Compartments The driver’s door has a To open the glove box door, squeeze the buttons. mapktorage compartment.
Page 59 Theft New Vehicle “Break-In’’ Vehicle theft is big business, especially in some cities. Although your Geo has a number of theft-deterrent NOTICE: features, we know that nothing we put on it can make it impossible to steal. However, there are ways you can help. Your modern Geo doesn’t need an elaborate “break-in.”...
Page 60 ACC (B): In this position you can operate some of your Ignition Switch electrical power accessories (such as the radio, but not the ventilation fan). It unlocks the steering wheel and ignition. ON (C): The switch returns to this position after you start your engine and release the switch.
Page 61 Starting Your Engine Automatic transaxle: NEUTRAL Move your shift lever to PARK (P) or (N). Your engine won’t start in other position that’s a safety feature. restart when you’re already moving, use NEUTRAL (N) only. NOTICE: Don’t try to shift to your Geo is PARK moving.
Page 62 To start your L4 engine: When your engine has run about seconds to warm up, your vehicle is ready to be driven. Don’t “race” 1. Without pushing the accelerator pedal, turn your your engine when it’s cold. ignition key to START. When the engine starts, let If the weather is below freezing (32°F or O”C), let go of the key.
Page 63 Driving Through Deep Standing NOTICE: Water Your engine is designed to work with the electronics in your vehicle. If you add electrical NOTICE: parts or accessories, you could change the way the fuel injection system operates. Before adding If you drive too quickly through deep puddles electrical equipment, check with your dealer.
Page 64 Automatic Transaxle There are several different positions for your shift lever. PARK (P): This locks your front wheels. It’s the best position to use when you start your engine because your Ensure the shift lever is fully in range before PARK vehicle can’t move easily.
Page 65 REVERSE (R): Use this gear to back up. NOTICE: Shifting to REVERSE while your vehicle is moving forward could damage your transaxle. REVERSE only after your vehicle is Shift to stopped. To rock your vehicle back and forth to get out of snow, ice or sand without damaging your transaxle, see “Stuck: In Sand, Mud, Ice or Snow”...
Page 66 DRIVE (D): This position is for normal driving. If you NOTICE: (Continued) need more power for passing, and you’re: Don’t shift into SECOND (2) unless you are going Going less than about 27 mph (43 km/h), push your slower than 65 mph (105 km/h), or you can accelerator pedal about halfway down.
Page 67 Overdrive (Option) Manual Transaxle Five-Speed If your automatic transaxle has OVERDRIVE, you can use it for better fuel economy. After starting your engine, always push in the OVERDRIVE switch. Then This is your shift pattern. Here’s how to operate your select the gear you want and press the accelerator pedal.
Page 68 You can shift into FIRST (1) when you’re going less NOTICE: than 20 mph (32 km/h). If you’ve come a complete stop and it’s hard to shift into FIRST (1), put the shift Shift to REVERSE (R) only after your vehicle lever in NEUTRAL (N) and let up on the clutch.
Page 69 Parking Brake If your speed drops below 20 mph (32 or if the engine is not running smoothly, you should downshift to the next lower gear. You may have to downshift two or more gears to keep the engine running smoothly or for good performance.
Page 70 NOTICE: Driving with the parking brake on can cause your rear brakes to overheat. You may have to replace them, and you could also damage other parts of your vehicle. If you are towing a trailer, see “Towing a Trailer” in the Index.
Page 71 Shifting Into PARK (P) (Automatic Transaxle Models Only) Move the shift lever into PARK (P) by holding in the button on the lever and pushing the lever all the toward the front of your vehicle. Move the key to LOCK. Remove the key and take it with you.
Page 72 Leaving Your Vehicle With the If you cannot shift PARK (P), ease pressure on push the shift lever all the way into the shift lever Engine Running PARK (P) and release the shift lever button as you (Automatic Wansaxle Models Only) maintain brake application.
Page 73 Parking Over Things That Burn Engine Exhaust...
Page 74 Running Your Engine While You’re Parked (Automatic Transaxle) It’s better not to park with the engine running. But if you ever have to, here are some things to know. Follow the proper steps to be sure your vehicle won’t move, See “Shifting Into PARK (P)” in the Index. If you are parking on a hill and if you’re pulling a trailer, also see “Towing a Trailer”...
Page 75 Windows The switch for the driver’s window has an Express Down feature. To use Express Down, push the switch Manual Windows down all the way. Release the switch and the window will lower completely. Use the window crank to open and each window.
Page 76 Tilt Wheel (Option) The Turn Signal/Lamps Control/Headlamp Beam Lever The lever on the left side the steering column includes your: A tilt steering wheel allows you to adjust the steering Turn Signal and Lane Change Indicator wheel before you drive. Headlamp High-Low Beam and Passing Signal You can also raise it to the highest level to give your legs more room when you exit and enter the vehicle.
Page 77 A green arrow on the Turn Signal and Lane Change Indicator inskment panel will flash The turn signal has two in the direction of the turn upward (for right) and two downward (for left) positions. These positions allow you to signal a turn or a lane change.
Page 78 Headlamp HighILow Beam Turn the outside portion of the lever to control the First, you must have the lamps. There are three headlamps on. For high positions for the lamp beams, push the turn signal switch. lever away from you. When the high beams are on, blue light on the instrument panel also will be on.
Page 79 Interior Lights Reading Lamp Dome Lamp The dome lamp has a three position switch. If you have a sunroof, you have a reading lamp near the The lamp comes on and stays on whether or not a sunroof switch. Press the switch to turn the lamp on and door is open.
Page 80 Windshield Wiper/Washer Lever Brightness Control This knob controls the The lever the right side brightness of your of the steering column controls the windshield instrument panel lights. Turn the knob clockwise to wipers and washer. brighten the lights or counterclockwise to dim them.
Page 81 LO: The wipers will run continuously at low speed. The wipers will continuously at high speed. MIST: (If you have mist-type wipers, the lever doesn’t have an position.) For a single wiping cycle, push the lever to MIST. Hold it there for a second, then let go. The wipers will stop after one cycle.
Page 82 Cruise Control (Option) With cruise control, you can maintain a speed of about 25 mph (40 k m h ) or more without keeping your foot on the accelerator. This can really help on long trips. Cruise control does not work at speeds below about 25 mph (40 km/h).
Page 83 2. Get up to the speed you To Set Cruise Control want. 1. Push the end of the 3. Push the lever down to cruise control lever. The SETICOAST and green CRUISE light on release it. the instrument panel will come on.
Page 84 To Increase Speed While Using Cruise To Resume a Set Speed Control Suppose you set your cruise control at a desired speed and then you apply the brake. This, of course, shuts off There are two ways to go to a higher speed. Here’s the the cruise control.
Page 85 To Reduce Speed While Using Cruise be too much trouble and don’t use cruise control on steep hills. Control To Get Out of Cruise Control There are two ways to reduce your speed while using cruise control: There are several ways to turn off the cruise control: Push the lever to SETKOAST until you reach the Step lightly on the brake pedal or push the clutch lower speed you want, then release it.
Page 86 Mirrors Convex Outside Mirror Your passenger’s side mirror may be convex. Inside Daymight Rearview Mirror A convex mirror’s surface is curved so you can see more from the driver’s seat. An inside rearview mirror is attached to your roof. The mirror has a pivot so that you can adjust it up and down Manual Adjust Mirrors or side to side.
Page 87 Electric Mirn C ktrol (Option) Sun Visors The electric mirror control is to the left of your steering wheel. To adjust either mirror, move the switch to LEFT (L) or RIGHT (R). Then use the round touch pad to adjust the mirror. When you are done adjusting the mirrors, move the control back to the center.
Page 88 Visor Vanity Mirrors (Option) Sunroof Swing down the sun visor, Pull down t.he cover to You can or open your sunroof. To tilt the sunroof, tilt expose the vanity mirror. press the switch marked UP. Press the other end of the switch to lower the sunroof.
Page 89 If the sunroof will not close, follow these instructions: I . Remove the cover screw (use a cross-recess screwdriver) and take off the sunroof control cover. To open the sunroof, push the SLIDE arrow that points 2. Carefully remove the inside screw, washers and to the rear of the vehicle.
Page 90 Be sure to have the sunroof checked by your Chevrolet/Geo dealer as soon as possible. Pull the door to open the ashtray. To remove it, push down on the part marked PUSH at the back, then pull...
Page 91 Rear Ashtray Cigarette Lighter To use the lighter, push the lighter in all the way and let go. When it's ready, it will pop back by itself. The lighter won't work if the key is in LOCK. NOTICE: You have an ashtray behind the console. Pull on the top Don't hold a cigarette lighter in with your hand of the door to open it.
Page 92 Instrument Panel 2-42...
Page 93 1. Side Window Defogger Vents 13. Ashtray 2. Brightness Control 14. Coinholder 3. Turn SignaVLamps ControUHeadlamp Beam Lever 15. Shift Lever 4. Instrument Cluster 16. Cigarette Lighter 5. Windshield Wiper Control 17. Cruise Control 6. Windshield Washer Button 18. Ignition Switch 7.
Page 94 Standard Cluster Your instrument cluster is designed to let you know at a your fuel tank, and many other things you’ll need to glance how your vehicle is running. You’ll know how know to drive safely and economically. fast you’re going, about how much fuel you have left in 2-44...
Page 95 Optional Cluster UNLEADED FUEL ONLY If you have the optional cluster, your instrument panel This cluster includes a tachometer. gives you additional information. 2-45...
Page 96 Warning Lights, Gages and Speedometer and Odometer Indicators Your speedometer lets you see your speed in both miles per hour (mph) and kilometers per hour (kmh). Your This part describes the warning lights and gages that odometer shows how far your vehicle has been driven, may be on your vehicle.
Page 97 When one of the wa ng lights comes on and stays on Air Bag Readiness Light when you are driving, or when one of the gages shows There is an bag readiness light on the instrument panel, there may be a problem, check the section that tells you which shows BAG on it.
Page 98 Brake System Warning Light Charging System Light This red light will come on Your Geo’s hydraulic brake system is divided into two briefly when you turn on the ignition, but the engine is parts. If one part isn’t working, the other part can not running, as a check to still work and stop you.
Page 99 System Warning Light?’ and “Towing Your Vehicle” Anti-Lock Brake System Warning Light the Index.) (Option) With the anti-lock brake system, this light will come when you start your engine and it will stay on for-three seconds. That’s normal. If the light doesn’t come on, have it fixed so it will be ready to warn you if there is a problem.
Page 100 Anti-Lock Brake System Active Light (Option) When your anti-lock system is adjusting brake pressure to help avoid braking skid, the ABS ACTIVE light will come on. Slippery road ACTIVE ACTIVE conditions may exist if this light comes on, so adjust driving your accordingly.
Page 101 Engine Coolant Temperature Gage Door Warning Light This red light stays on if door is not completely closed. The light should also come on briefly when you turn your key to START. If the light doesn’t come on as it should, have it fixed.
Page 102 Malfunction Indicator Lamp (Check Engine Light) If you keep driving your vehicle with this light A computer monitors on, after a while the emission controls won’t operation of your fuel, work as well, your fuel economy won’t be as good ignition and emission and your engine may not run as smoothly.
Page 103 Engine Oil Pressure Light Sometimes when the engine is idling at a stop, the light may blink on and off. This is normal. If you have a problem, with If you make hard stop, the light may come on for a your oil, this red light may moment.
Page 104 Here are five concerns some owners have had about the Fuel Gage fuel gage. All these situations are normal and do not indicate that anything is wrong with the fuel gage. At the gas station, the fuel pump shuts off before the gage reads FULL (F).
Page 105 Overdrive Off Light Rear Window Defogger Light If you have an automatic This amber light will come transaxle with on whenever the rear OVERDRIVE, this amber window defogger is on. See light appears on your “Rear Window Defogger” instrument cluster. The light in the Index.
Page 106 NOTES 2-56...
Page 107 Section 3 Comfort Controls and Audio Systems In this section you'll find out how to operate the comfort With this system you can control the heating and ventilation in your Geo. If you have the air conditioning control systems and audio systems offered with your Geo.
Page 108 Fan Knob Heating FAN: Turn the knob away from OFF to turn the heating For the quickest results, move the air intake lever to RECIRCULATE and the airflow knob to FLOOR. system on. Turn the knob toward HI to increase the fan’s speed.
Page 109 A/C: Push this button to change your comfort control Defogging and Defrosting Windows system from heating to air conditioning. A light will Move the air intake lever to CIRCULATE and turn come on when the air conditioning is on. The A/C the airflow knob to DEFROST to direct air to the button can also control the humidity in your vehicle.
Page 110 Rear Window Defogger (Option) NOTICE: Don’t use a razor blade or something else sharp on the inside of the rear window. If you do, you could cut or damage the warming grid, and the remove fog from repairs wouldn’t be covered by your warranty. the rear window.
Page 111 AM-FM Stereo with Cassette Tape Player Keep the air path under the front seats clear of objects. This helps air to circulate throughout your vehicle. To set the correct hour, press and hold RCLPROG (TIME SET). At the same time, press and hold Shut off outboard dash vents to keep cold air from TUNE (HR) until the correct hour appears.
Page 112 AM-FM Stereo Finding a Station AM-FM: Press this button to get AM or FM. The lighted display shows your selection. TUNE: Press TUNE or TUNE to go to a higher or lower station. Press and hold to continue tuning and release when you find your station.
Page 113 Setting the Tone AM-FM Stereo with Cassette Tape Player TREB: Turn this knob to the right to hear more treble. BASS: Turn this control behind the TREB knob to the right to hear more bass. Adjusting the Speakers FADE: Turn this knob to move the sound between the front and rear speakers.
Page 114 Setting the Tone Finding a Station TREB: Turn this knob to the right to hear more treble. AM-FM: Press this button to get AM, FM1 or FM2. The lighted display shows your selection. BASS: Turn this control behind the TREB knob to the TUNE: Press TUNE b or TUNE 4 to go to a higher right to hear more bass.
Page 115 Recall REW Press this button to reverse the tape rapidly. Press REW or RCLPROG to return to playing speed. If you RCL: Press this button to see the station being played press RCLPROG, the tape will also change sides. for a moment. Or, press it if you want to see the time when the ignition is off.
Page 116 RADIO MNTR: Press this button to hear the radio Write down any four-digit number and keep it in a safe place. Then turn the ignition switch to the ACC or ON when you are fast forwarding or reversing a cassette position and the audio system off.
Page 117 To Unlock the System After a Power Loss How to Shut Off the Theft-Deterrent Feature If power is disrupted to the radio while in the SEC If your radio is secured (SEC shows on the display) and you wish to disable it, enter your security code as mode, the unit will not work and LOC will show on the follows, pausing no more than 15 seconds between display whenever the ignition is on.
Page 118 Finding a Station AM-FM Stereo with Cassette Tape and Compact Disc Players AM-FM: Press AM-FM to get FMl or FM2. The lighted display shows your selection. or TUNE 4 to go to a higher or TUNE: Press TUNE lower station. Release when you find your station. The display will show the frequency of each station tuned.
Page 119 Setting the Tone Recall TREB: Turn this knob to the right to hear more treble. RCL: Press to see the station being played for a moment. Or, press it if you want to see the time when BASS: Turn this control behind the TREB knob to the the ignition is off.
Page 120 RDM: When playing a tape, press this button during Press this button to reverse the tape rapidly. Press FF or REW to hear the radio. Press it again to turn the REW, RCL or STOP to return to playing speed. If V A , radio off.
Page 121 To Play a Compact Disc NXT Press this button to hear the next track now (instead of waiting until the present track is finished). Don’t the mini-discs (three-inch singles). They won’t eject. Use full-size compact discs. If you hold this button, or press it more than once, the disc will advance further.
Page 122 Theft-Deterrent Feature You are now ready to enter your security code. Don’t wait more than 15 seconds between steps. The theft-deterrent feature for the AM-FM stereo with Press SEEK 4 b andor TUNE cassette tape and compact disc player can be used or and “0000”...
Page 123 How to Shut Off the Theft-Deterrent Feature To Unlock the System After a Power Loss If your radio is secured (SEC shows on the display) and If power is disrupted to the radio while in the SEC you wish to disable it, enter your security code as mode, the unit will not work and LOC will show on the follows, pausing no more than 15 seconds between display whenever the ignition is on.
Page 124 To help avoid hearing loss or damage: Understanding Radio Reception Adjust the volume control to the lowest setting. Stereo Increase volume slowly until you hear comfortably FM stereo will give you the best sound. But FM signals and clearly. will reach only about 10 to 40 miles (16 to 65 km).
Page 125 Care of Your Cassette Tape Player the tape head. This type of cleaning cassette will not eject. It may not clean as thoroughly as the scrubbing A tape player that is not cleaned regularly can cause type cleaner. reduced sound quality, ruined cassettes, or a damaged Cassettes are subject to wear and the sound quality may mechanism.
Page 126 NOTES 3-20...
Page 127 GetB Section 4 Your Driving and the Road Defensive Driving The best advice anyone can give about driving is: Drive defensively. Please start with a very important safety device in your Geo: Buckle up. (See “Safety Belts” in the Index.) Defensive driving really means “be ready for anything.”...
Page 128 The obvious way to solve this highway safety problem Drunken Driving is for people never to drink alcohol and then drive. But Death and injury associated with drinking and driving what if people do? How much is “too much” if the a national tragedy.
Page 129 woman generally will reach a higher BAC level than a man of her same body weight when each has the same number of drinks. The law in many U.S. states sets the legal limit at a BAC of 0.10 percent. In a growing number of U.S. states, and throughout Canada, the limit is 0.08 percent.
Page 130 The body takes about an hour to rid itself of the alcohol in one drink. No amount of coffee or number of cold showers will speed that up. “I’ll be careful” isn’t the right answer. What if there’s an emergency, a need to take sudden action, as when a child darts into the street? A person with even a moderate BAC might not be able to react quickly enough to avoid the collision.
Page 131 Control of a Vehicle Braking You have three systems that make your vehicle go where Braking action involves perception time and reaction you want it to go. They are the brakes, the steering and time. the accelerator. All three systems have to do their work First, you have to decide to push on the brake pedal.
Page 132 Avoid needless heavy braking. Some people drive And this light on the in spurts heavy acceleration followed by heavy instrument panel will come braking rather than keeping pace with traffic. This on briefly when you start is a mistake. Your brakes may not have time to cool your ve hicle.
Page 133 The anti-lock system can change the brake pressure faster than any driver could. The computer is programmed to make the most of available tire and road conditions. Here’s how anti-lock works. Let’s say the road is wet. You’re driving safely. Suddenly an animal jumps out in front of you.
Page 134 Remember: Anti-lock doesn’t change the time you need first reaction to hit the brake pedal hard and hold it to get your foot up to the brake pedal. If you get too down may be the wrong thing to do. Your wheels can stop rolling.
Page 135 Suppose you’re steering through a sharp curve. Steering Then you suddenly apply the brakes. Both control Power Steering systems steering and braking have to do their work where the tires meet the road. Unless you have If you lose power steering assist because the engine four-wheel anti-lock brakes, adding the hard braking stops or the system is not functioning, you can steer but can demand too much of those places.
Page 136 Steering in Emergencies There are times when steering can be more effective than braking. For example, you come over a hill and find a truck stopped in your lane, or a car suddenly pulls out from nowhere, or a child darts out from between parked cars and stops right in front of you.
Page 137 Passing Off-Road Recovery The driver of a vehicle about to pass another on a You may find sometime that your right wheels have dropped off the edge of a road onto the shoulder while two-lane highway waits for just the right moment, accelerates, moves around the vehicle ahead, then goes you’re driving.
Page 138 Do not get too close to the vehicle you want to pass ahead of the passed vehicle to see its front in your while you’re awaiting an opportunity. For one thing, inside mirror, activate your right lane change signal following too closely reduces your area of vision, and move back into the right lane.
Page 139 Skidding want to slow down and adjust your driving to these conditions. It is important to slow down on slippery In a skid, a driver can lose control of the vehicle. surfaces because stopping distance will be longer and Defensive drivers avoid most skids by taking reasonable vehicle control more limited.
Page 140 Driving at Night Don't drink and drive. Adjust your inside rearview mirror to reduce the glare from headlamps behind you..Since you can't see as well, you may need to slow down and keep more space between you and other vehicles.
Page 141 You can be temporarily blinded by approaching Driving in the Rain headlamps. It can take a second or two, or even several seconds, for your eyes to readjust to the dark. When you are faced with severe glare (as from a driver who doesn’t lower the high beams, or a vehicle with misaimed headlamps), slow down a little.
Page 142 The heavier the rain, the harder it is to see. Even if your Driving too fast through large water puddles or even windshield wiper blades are in good shape, a heavy rain going through some car washes can cause problems, too. The water may affect your brakes.
Page 143 Some Other Rainy Weather Tips Hydroplaning Turn on your low-beam headlamps not just your Hydroplaning is dangerous. much water can build up parking lamps to help make you more visible to under your tires that they can actually ride on the water. This can happen if the road is wet enough and you’re others.
Page 144 City Driving One of the biggest problems with city streets is the amount of traffic on them. You’ll want to watch out for what the other drivers are doing and pay attention to traffic signals. Here are ways to increase your safety in city driving: Know the best way to get to where you are going.
Page 145 Freeway Driving The most important advice on freeway driving is: Keep up with traffic and keep to the right. Drive at the same speed most of the other drivers are driving. Too-fast or too-slow driving breaks a smooth traffic flow. Treat the left lane on a freeway as a passing lane.
Page 146 When you want to leave the freeway, move to the proper Chevrolet/Geo dealers all across North America. They’ll lane well in advance. If you miss your exit do not, under be ready and willing to help if you need it.
Page 147 Hill and Mountain Roads Highway Hypnosis Is there actually such a condition as “highway hypnosis”? Or is it just plain falling asleep at the wheel? Call it highway hypnosis, lack of awareness, or whatever. There is something about an easy stretch of road with the same scenery, along with the hum of the tires on the road, the drone of the engine, and the rush of the wind against the vehicle that can make you sleepy.
Page 148 If you drive regularly in steep country, or if you’re planning to visit there, here are some tips that can make your trips safer and more enjoyable. Keep your vehicle in good shape. Check all fluid levels and also the brakes, tires, cooling system and transaxle.
Page 149 Winter Driving Include an ice scraper, a small brush or broom, a supply of windshield washer fluid, a rag, some winter outer clothing, a small shovel, a flashlight, a red cloth, and a Here are some tips for winter driving: couple of reflective warning triangles.
Page 150 Driving on Snow or Ice What’s the worst time for this? “Wet ice.” Very cold snow or ice can be slick and hard to drive on. But wet Most of the time, those places where your tires meet the ice can be even more trouble because it may offer the road probably have good traction.
Page 151 If You’re Caught in Blizzard Remember, unless you have anti-lock, if you brake so hard that your wheels stop rolling, you’ll just slide. Brake so your wheels always keep rolling and you can still steer. Whatever your braking system, allow greater following distance on any slippery road.
Page 152 cloth to your vehicle to alert police that you’ve been stopped by the snow. Put on extra clothing or wrap a blanket around you. If you have no blankets or extra clothing, make body insulators from newspapers, burlap bags, rags, floor mats anything you can wrap around yourself or tuck under your clothing to keep warm.
Page 153 Then, shut the engine off and close the window almost size, speed rating and recommended inflation pressures all the way to preserve the heat. Start the engine again for the tires on your vehicle. It also gives you important and repeat this only when you feel really uncomfortable information about the number of people that can be in from the cold.
Page 154 Never exceed the GVWR your vehicle, or the Gross If you put things inside your vehicle like suitcases, Axle Weight Rating (GAWR) for either the front or rear fast tools, packages, or anything else they will go as axle. as the vehicle goes. If you have to stop or turn quickly, if there is a crash, they’ll keep going.
Page 155 To identify what the vehicle trailering capacity is for Towing a Trailer your vehicle, you should read the information in “Weight of the Trailer” that appears later in this section. But trailering is different than just driving your vehicle by itself. Trailering means changes in handling, durability, and fuel economy.
Page 156 Your engine, axle or other parts could be damaged. Customer Assistance Department Chevrolet/Geo Then, during the first 500 miles (800 km) that you P.O. Box 7047 tow a trailer, don’t drive over 50 mph (80 M h ) and Troy, MI 48007-7047 don’t make starts at full throttle.
Page 157 Weight of the Trailer Tongue If you’re using a “dead-weight” hitch, the trailer tongue (A) should weigh 10% the total loaded trailer weight The tongue load (A) of any trailer is an important (B). If you have a “weight-distributing” hitch, the trailer weight to measure because it affects the total capacity tongue (A) should weigh 12% of the total loaded trailer weight of your vehicle.
Page 158 manufacturer’s recommendation for attaching safety chains and do not attach them to the bumper. Always It’s important to have the correct hitch equipment. leave just enough slack so you can turn with your rig. Crosswinds, large trucks going by, and rough roads are a And, never allow safety chains to drag on the ground.
Page 159 Following Distance Driving with a Trailer Towing a trailer requires a certain amount of experience. Stay at least twice as far behind the vehicle ahead as you would when driving your vehicle without a trailer. This Before setting out for the open road, you’ll want to get to know your rig.
Page 160 Making Turns When towing a trailer, the green arrows on your instrument panel will flash for turns even if the bulbs on the trailer are burned out. Thus, you may think drivers NOTICE: behind you are seeing your signal when they are not. It’s important to check occasionally to be sure the trailer Making very sharp turns while trailering could bulbs are still working.
Page 161 When You Are Ready to Leave After Parking on Hills Parking on a Hill You really should not park your vehicle, with a trailer attached, on a hill. If something goes wrong, your rig 1. Apply your regular brakes and hold the pedal down could start to move.
Page 162 NOTES 4-36...
Page 163 Problems on the Road Section 5 Here you’ll find what to do about some problems that Your hazard warning flashers let you warn others. They can occur on the road. also let police know you have a problem. Your front and rear turn signal lamps will flash and off.
Page 164 Your hazard warning flashers work no matter what position your key is in, and even if the key isn’t in. off the flashers, press the button again. turn When the hazard warning flashers are on, your turn signals won’t work. Other Warning Devices If you carry reflective triangles, you can set one up at the side of the road about 300 feet (100 m) behind your...
Page 165 To Jump Your Geo Start NOTICE: 1. Check the other vehicle. It must have a 12-volt battery with a negative ground system. you leave your radio on, it could be badly damaged. The repairs wouldn’t be covered by your warranty. NOTICE: If the other system isn’t 12-volt system with a...
Page 166 the jumper cables don’t have loose or Check that missing insulation. If they do, you could get a shock. vehicles could be damaged, too. Before you connect the cables, here some basic things you should know. Positive will go to positive and negative will go to negative...
Page 167 The other end of the negative cable duesn go to the ’t dead battery. It goes to a heavy unpainted metal part on the engine of the vehicle with the dead battery. 6. Connect the red positive cable to the positive terminal of the vehicle with the dead battery.
Page 168 T r y Towing Your Vehicle start the vehicle with dead battery. If it won’t start after a few tries, it probably needs service. I-c+I 12. Remove the cables in reverse order to prevent Try to have a GM dealer or a professional towing electrical shorting.
Page 169 lamps, aero skirting, or special tires and wheels, these instructions and illustrations may not be correct. Before you do anything, turn on the hazard warning flashers. When you call, tell the towing service: That your vehicle cannot be towed from the front or rear with sling- type equipment.
Page 170 Don’t have your vehicle towed with the front wheels in contact with the ground if it has an automatic transaxle. If a vehicle with an automatic transaxle must be towed from the rear with wheel lift equipment, the front wheels must be supported on a dolly.
Page 171 Front Towing Hook-Ups Attach T-hook chains to slots in the frame brackets just ahead of the front wheels on both sides. NOTICE: Do not tow with sling-type equipment or fascia damage will occur. NOTICE: (Continued)
Page 172 Rear Towing Hook-Ups NOTICE: (Continued) Use wheel lift or car carrier equipment. Additional ramping may be required for car carrier equipment. Use safety chains and wheel straps. Attach T-hook chains to slots in the bottom of the floor pan just ahead of the rear wheels on both sides. Attach a separate safety chain around the outboard end of each lower control arm.
Page 173 NOTICE: (Continued) Use safety chains and wheel straps. Dollies are required under the front wheels damage will occur. NOTICE: Do not tow with sling-type equipment or rear bumper valance will be damaged. Use wheel lift or car carrier equipment. Attach a separate safety chain around the outboard end Additional ramping may be required for car of each lower control arm.
Page 174 Engine Overheating You will find a coolant temperature gage or the warning light about a hot engine your Geo instrument panel. If Steam Is Coming From Your Engine NOTICE: If your engine catches fire because you keep driving with no coolant, your vehicle can be badly damaged.
Page 175 If No Steam Is Coming From Your Engine If you no longer have the overheat warning, you can drive. Just to be safe, drive slower for about 10 minutes. If you get the overheat warning but see or hear no If the warning doesn’t come back on, you can drive steam, the problem may not be too serious.
Page 176 Cooling System If the coolant inside the coolant recovery tank is boiling, don’t do anything else until it cools down. When you decide it’s safe to lift the hood, here’s what you’ll see: 1. Coolant Recovery Tank 2. Radiator Pressure Cap 3.
Page 177 If there seems to be no leak, with the engine on check to see if the electric engine fan is running. If the engine is overheating, the fan should be running. If it isn’t, your vehicle needs service. How to Add Coolant to the Coolant Recovery Tank If you haven’t found a problem yet, but the coolant level isn’t at FULL, add a 50150 mixture of clean water...
Page 178 When the coolant in the coolant recovery tank is at FULL, start your vehicle. 5-16...
Page 179 If the overheat warning continues, there's one more thing you can try. You can add the proper coolant .directly to the radiator, but be sure the cooling system is cool before you do it. 5-17...
Page 180 How to Add Coolant to the Radiator 2. Then keep turning the pressure cap, but now push down as you turn it. Remove the pressure cap. 1. You can remove the radiator pressure cap when the cooling system, including the radiator pressure cap and upper radiator hose, is no longer hot.
Page 181 3. Fill the radiator with the proper mix, up to the base 4. Then fill the coolant recovery tank to FULL. of the filler neck. 5. Put the cap back on the coolant recovery tank, but leave the radiator pressure cap off. 5-19...
Page 182 8. Replace the thermostat, making sure it is properly inserted, then replace the pressure cap. At any time during this procedure if coolant begins to flow out of the filler neck, reinstall the pressure cap. Be sure the 6. Start the engine and let it run until you can feel the arrows on the pressure cap line up like this.
Page 183 If a Tire Goes Flat Changing a Flat Tire It’s unusual for a tire to “blow out” while you’re driving, If a tire goes flat, avoid further tire and wheel damage especially if you maintain your tires properly. If air goes by driving slowly to a level place.
Page 184 The following steps will tell you how to use the jack and change a tire. The equipment you’ll need is in the trunk. 1. Move the carpet from the top of the spare tire cover. Then remove the cover over the spare tire. 2.
Page 185 4. Remove the wheel wrench (A), jack (B) and jack 5. Attach the jack handle to the jack. Turn the jack handle (C) from the trunk. handle to the right to raise the lift head. The jack is under a cover on the right side of the trunk.
Page 186 7. Insert the flat end of the wheel wrench into the slot 6. Remove the wheel cover, if your vehicle is equipped remove the center cap, if your vehicle is equipped with one, by using the flat end of the wheel wrench. with one.
Page 187 8. Using the wheel wrench, loosen all the wheel nuts. 9. Position the jack and raise the jack lift head until it Don’t remove them yet. fits firmly into the notches closest to the flat tire. (Under the vehicle near each wheel, there are bosses in the vehicle’s rocker flange.) The jack head groove fits the rocker flange forward of the boss in the front;...
Page 188 NOTICE: Raising your vehicle with the jack improperly positioned will damage the vehicle or may allow the vehicle to fall off the jack. Be sure to fit the jack lift head into the proper location before raising your vehicle. 10. Raise vehicle by rotating the jack handle clockwise.
Page 189 11. Remove all the wheel nuts and take off the flat tire. 12. Remove any rust or dirt from the wheel bolts, mounting surfaces and spare wheel. Place the spare on the wheel mounting surface. 5-27...
Page 190 13. Replace the wheel nuts with the rounded end of the nuts toward the wheel. Tighten each nut by hand until the wheel is held against the hub. 14. Lower the vehicle by turning the jack handle counterclockwise. Lower the jack completely. 5-28...
Page 191 Don’t try to put a wheel cover on your compact spare 15. Tighten the wheel nuts firmly in a criss-cross tire. It won’t fit. Store the wheel cover in the trunk until you have the flat tire repaired or replaced. sequence as shown.
Page 192 Compact Spare Tire Although the compact spare was fully inflated when your vehicle was new, it can lose air after a time. Check the inflation pressure regularly. It should be 60 psi (420 kPa). After installing the compact spare on your vehicle, you should stop as soon as possible and make sure your spare tire is correctly inflated.
Page 193 If You’re Stuck: In Sand, Mud, NOTICE: Ice or Snow Don’t take your compact spare through an What you don’t want to do when your vehicle is stuck is automatic car wash with guide rails. The to spin your wheels too fast. The method known as compact spare can get caught on the rails.
Page 194 Using the Recovery Hooks NOTICE: Your vehicle is equipped with recovery hooks. The recovery hooks are provided at the front of your vehicle. Spinning your wheels can destroy parts of your They can only be used for pulling your vehicle out. vehicle as well as the tires.
Page 195 There is also technical information about your vehicle, and a part devoted to its appearance care. Service Your Chevrolet/Geo dealer knows your vehicle best and wants you to be happy with it. We hope you’ll go to your dealer for all your service needs. You’ll get genuine GM parts and GM-trained and supported service people.
Page 196 Doing Your Own Service Work If you want to do some of your own service work, you’ll want to get the proper Geo Service Manual. It tells you much more about how to service your Geo than this manual can. To order the proper service manual, see “Service Publications’’...
Page 197 Fuel What about gasoline with blending materials that contain oxygen (oxygenates), such as MTBE or alcohol? Use regular unleaded gasoline rated at 87 octane or MTBE is “methyl tertiary-butyl ether.’’ Fuel that is no higher. It should meet specifications ASTM D4814 in more than 15% MTBE is fine for your vehicle.
Page 198 Gasolines for Cleaner Air Fuels in Foreign Countries Your use of gasoline with deposit control additives will plan on driving in another country outside the help prevent deposits from forming your engine and U.S. or Canada, unleaded fuel may be hard to find. Do fuel system.
Page 199 Filling Your Tank Remote Fuel Door Release Lever of the driver’s seat. The cap is behind a hinged door on the driver’s side of your vehicle. To take off the cap, turn it slowly to the left (counterclockwise).
Page 200 Checking Things Under the Hood Hood Release To open the hood, first pull the release handle inside the vehicle. 1t’s.near the floor to the left of the steering wheel. Be careful not to spill gasoline. Clean gasoline from painted surfaces as soon as possible. See “Cleaning the Outside of Your Geo”...
Page 201 Then go to the front of the vehicle. Release the secondary hood release by pushing up on the lever near the middle the hood. Lift the hood, release the hood prop from its retainer and put the hood prop into the slot in the hood.
Page 203 When you open the hood, on the 1.6L (Code 6) engine without anti-lock brakes you’ll see: 1. Windshield Washer Reservoir 2. Oil Fill Cap 3. Engine Oil Dipstick 4. Power Steering Reservoir 5. Brake Fluid Reservoir 6. Air Cleaner 7. Engine Compartment Fuses 8.
Page 204 6-10...
Page 205 When you open the hood, on the 1.8L (Code 8) engine with anti-lock brakes you’ll see: Windshield Washer Reservoir Oil Fill Cap Engine Oil Dipstick Power Steering Fluid Reservoir Brake Fluid Reservoir Air Cleaner Engine Compartment Fuses Before closing the hood, be sure all the filler caps are on properly.
Page 206 To Check Engine Oil Engine Oil Pull out the dipstick and clean it with a paper towel or a It’s a good idea to check your engine oil level every time cloth, then push it back in all the way. Remove it again, you get fuel.
Page 207 When Add Oil If the oil is at or below the “L,” you’ll need to add some oil. But you must use the right kind. This part explains what kind of oil to use. For crankcase capacity, see “Capacities and Specifications” in the Index. NOTICE: Don’t add too much oil.
Page 208 What Kind of Oil to Use RECOMMENDED SAE VlSCOSlW GRADE ENGINE OILS Oils of the proper quality for your vehicle can be FOR BEST FUEL ECONOMY AND COLD S SELECT THE LOWEST ----6, identified by looking for the “Starburst” symbol. The SAE VISCOSITY GRADE OIL FOR THE EX~CVBLY TEMPERATURE RANGE.
Page 209 As shown in the chart, SAE 1OW-30 is best for your When to Change Engine Oil vehicle. However, you can use S A E 5W-30 if it’s See if any one of these is true for you: going to be colder than 60°F (1 6 before your next oil change.
Page 210 Air Cleaner What to Do with Used Oil Did you know that used engine oil contains certain elements that may be unhealthy for your skin and could even cause cancer? Don’t let used oil stay on your skin for very long. Clean your skin and nails with soap and water, or a good hand cleaner.
Page 211 Air Filter Replacement To check or replace the filter: NOTICE: If the air cleaner is off, a backfire can cause a f i r e . damaging engine And, dirt can easily get into your engine, which will damage it. Always 1.
Page 212 Wait at least 30 minutes before checking the transaxle Automatic Transaxle Fluid fluid level if you have been driving: When to Check and Change When outside temperatures above 90°F (32°C). A good time to check your automatic transaxle fluid At high speed for quite a while. level is when the engine oil is changed.
Page 213 How to Add Fluid Then, without shutting off the engine, follow these steps: Refer to the Maintenance Schedule to determine what kind of transaxle fluid to use. See “Recommended Fluids and Lubricants” in the Index. If the fluid level low, add only enough of the proper fluid to bring the level into the area between dimples...
Page 214 2. Check that the lubricant level is up to the bottom of Because this operation can be difficult, you may choose the filler plug hole. to have this done at your Chevrolet/Geo dealer Service 3. If the fluid level is good, install the plug and be sure Department.
Page 215 When to Check and What to Use Hydraulic Clutch The hydraulic clutch linkage in your vehicle is self-adjusting. The clutch master cylinder reservoir is filled with hydraulic clutch fluid. It isn’t a good idea to “top off’ your clutch fluid. Adding fluid won’t correct a leak.
Page 216 How to Check Check to make sure that the fluid level is at the MIN mark. If the level is below the MIN mark, see the instructions on the reservoir cap. Engine Coolant The following explains your cooling system and how to add coolant when it is low.
Page 217 Adding Coolant Add coolant mix at the recovery tank, but be careful not to spill it. To Check Coolant When your engine cold, the coolant level should be at LOW, or a little higher. When your engine is warm, the level should be up to FULL, or a little higher.
Page 218 Power Steering Fluid Radiator Pressure Cap NOTICE: Your radiator cap is a 15 psi (105 P a ) pressure-type cap and must be tightly installed prevent coolant loss and possible engine damage from overheating. Be sure the arrows on the cap line up with the overflow tube on the radiator filler neck.
Page 219 How To Check Power Steering Fluid Unscrew the cap and wipe the dipstick with a clean rag. Replace the cap and completely tighten it. Then remove the cap again and look at the fluid level the dipstick. When the engine compartment is hot, the level should be between the HOT marks.
Page 220 Open the cap labeled WASHER FLUID ONLY. Add Windshield Washer Fluid is full. washer fluid until the tank What to Use When you need windshield washer fluid, be sure to read NOTICE: the manufacturer’s instructions before use. I f you will be When using concentrated washer fluid, operating your vehicle in an area where the temperature follow the manufacturer’s instructions for...
Page 221 Brakes Brake Master Cylinder Your brake master cylinder is here. It is filled with DOT-3 brake fluid. If you have anti-lock brakes, open the cap labeled WASHER FLUID ONLY. Add washer fluid until the float in the tank shows that it is full. There are only two reasons why the brake fluid level ’...
Page 222 your brake fluid. Adding brake fluid won’t correct a What leak. If you add fluid when your linings are worn, then When you do need brake fluid, use only DOT-3 brake you’ll have too much fluid when get new brake -- such P a r t fluid...
Page 223 Some driving conditions or climates may cause a brake Brake Wear squeal when the brakes are first applied or lightly Your Geo has front disc brakes and rear drum brakes. applied. This does not mean something is wrong with your brakes. Disc brake pads have built-in wear indicators that make a high-pitched warning sound when the brake pads are Your rear drum brakes don’t have wear indicators, but if...
Page 224 If your brake pedal goes down farther than normal, your Battery rear drum brakes may need adjustment. Adjust them Every new Geo has a Delco Freedom’ battery. You backing up firmly applying the brakes few times. never have to add water to one of these. When it’s time Replacing Brake System Parts for a new battery, we recommend a Delco Freedom’...
Page 225 Headlamps Bulb Replacement See “Replacement Bulbs” in the Index to check the size and type of bulb you need to use. Halogen Bulbs 1. Open the hood. 2. If you’re replacing a driver’s side headlamp bulb, you need to remove the air duct behind the headlamp assembly.
Page 226 Front Sidemarker Lamps 3. Reach behind the headlamp assembly and find the lock ring assembly. 1. Remove the screw near the top outside of the 4. Turn the lock ring assembly counterclockwise. headlamp assembly. (It doesn’t come off.) a snap-in 2.
Page 227 Front Thrn Signal Lamps 4. Turn the bulb socket counterclockwise and pull it out. 1. Remove the screw in the parking lamp lens and 5. Push the bulb in, turn it counterclockwise and pull it remove the parking lamp assembly. out.
Page 228 Parking Lamps 3. Turn the bulb socket counterclockwise and pull the bulb straight out. 1. Remove the screw near the top outside part of the 4. Reverse the steps with a new bulb. headlamp assembly. 2. Remove the parking lamp assembly. There is a snap-in connector at the front of the assembly, so you may have to pry carefully on the inside edge of the assembly to remove it.
Page 229 Rear Combination Lamps 4. Remove the nut from the stud near the rear comer of The combination lamp assembly includes the the trunk. taillamp/stoplamp, turn signal and sidemarker bulbs. 1. Open the trunk. 2. Remove the two bolts from the lens assembly. 3.
Page 230 Back-up Lamps Remove the rear combination lamp assembly. There is a snap-in connector in the assembly, so you may Open the trunk. have to pull carefully on the inside edge of the assembly to remove it. Remove the trim on the trunk lid (if your vehicle is so equipped).
Page 231 Tires We don’t make tires. Your new vehicle comes with high-quality tires made by a leading tire manufacturer. These tires are warranted by the tire manufacturers, and their warranties are delivered with every new Geo. If your spare tire is a different brand than your road tires, you will have a tire warranty folder from each of these manufacturers.
Page 232 Inflation Tire Pressure NOTICE: (Continued) The Tire-Loading Information label which is in your your tires have too much (overinflation), glove compartment shows the correct inflation pressures you can get: for your tires, when they’re cold. “Cold” means your Unusual wear vehicle has been sitting for at least three hours or driven Bad handling no more than...
Page 233 Tire Inspection and Rotation Tires should be inspected every 6,000 to 8,000 miles (10 000 to 13 000 for any signs of unusual wear. If unusual wear is present, rotate your tires as soon as possible and check wheel alignment. Also check for damaged tires or wheels.
Page 234 When It’s Time for New Tires One way to tell when it’s time for tires is t( check the treadwear indicators, which will appear when your tires have only 1/16 inch (1.6 less of tread remaining. You need a new tire if You can see the indicators at three or more places around the tire.
Page 235 Buying New Tires Uniform Tire Quality Grading To find out what kind and size of tires you need, look at The following information relates to the system the Tire-Loading Information label. developed by the United States National Highway Traffic Safety Administration which grades tires by Make sure the replacements are the same size, load treadwear, traction and temperature performance.
Page 236 A, B, C Traction Warning: The temperature grade for this tire is established for a tire that is properly inflated and not The traction grades, from highest to lowest are: A, B, overloaded. Excessive speed, underinflation, or and C . They represent the tire’s ability to stop on wet excessive loading, either separately or in combination, pavement as measured under controlled conditions on can cause heat buildup and possible tire failure.
Page 237 (except some aluminum wheels, which can sometimes be repaired). See your Chevrolet/Geo dealer if any of these conditions exist. Your dealer will know the kind of wheel you need. Each new wheel should have the same load carrying capacity, diameter, width, offset, and be mounted the same way as the one it replaces.
Page 238 Used Replacement Wheels Tire Chains NOTICE: Use tire chains only where legal and only when you must. Use only SAE Class “S” type chains that are the proper size for your tires. Install them on the front tires and tighten them as tightly as possible with the ends securely fastened.
Page 239 Never use these to clean your vehicle: dirt. Wipe vinyl or leather with a clean, damp cloth. Gasoline Your Chevrolet/Geo dealer has two GM cleaners, a Benzene solvent-type spot lifter and a foam-type powdered cleaner. They will clean normal spots and stains very Naphtha well.
Page 240 Using Solvent-’Qpe Cleaner on Fabric Using Foam-Type Cleaner on Fabric First, see if have to use solvent-type cleaner at all, Vacuum and brush the area to remove any loose dirt. Some spots and stains will clean off better with just Always clean a whole trim panel or section.
Page 241 Combination Stains Special Cleaning Problems Stains caused by candy, ice cream, mayonnaise, chili Greasy or Oily Stains sauce and unknown stains can be removed as follows: Stains caused by grease, oil, butter, margarine, shoe polish, Carefully scrape off excess stain, then clean with coffee with cream, chewing gum, cosmetic creams, vegetable cool water and allow to dry.
Page 242 Cleaning the Top of the Instrument Panel Don’t use abrasive cleaners on glass, because they may cause scratches. Avoid placing decals on the inside rear Use only mild soap and water to clean the top surfaces window, since they may have to be scraped off later. If of the instrument panel.
Page 243 Weatherstrips High pressure car washes may cause water to enter your vehicle. Silicone grease on weatherstrips will make them last Finish Care longer, seal better, and not stick squeak. Apply silicone grease with a clean cloth at least every six Occasional waxing or mild polishing of your Geo by months.
Page 244 surfaces. Wash the vehicle Tires soon as possible. If necessary, use non-abrasive cleaners that are marked To clean your tires, use a stiff brush with tire cleaner. safe for painted surfaces to remove foreign matter. When applying a tire dressing always take care to wipe Exterior painted surfaces are subject to aging, weather off any overspray or splash from painted surfaces.
Page 245 Underbody Maintenance Chemical Paint Spotting Chemicals used for ice and snow removal and dust Some weather and atmospheric conditions can create a control can collect on the underbody. If these are not chemical fallout. Airborne pollutants can fall upon and removed, accelerated corrosion (rust) can occur on the attack painted surfaces on your vehicle.
Page 246 Appearance Care and Maintenance Materials from your GM Parts Department. can get these PART NUMBER SIZE USAGE DESCRIPTION 12345343 GoodwrenchB Liquid Wax Exterior polish (0.473L) 1052277 (0.354L) Spray-A-Squeak Silicone Grease Weatherstrips, Stops squeaks 1052863 1 oz. (0.028kg) 1050 172 T a r and Road Oil Remover Also removes old waxes, polishes (0.473L)
Page 247 Vehicle Identification Number (VIN) Engine Identification The eighth character in your VIN is the engine code. This code will help you identify your engine, specifications, and replacement parts. 1 G 1 A W 8 1 R 7 t G 1 0 0 1 0 1 ~ Service Parts Identification Label You’ll find this label on your spare tire cover.
Page 248 Fuses and Circuit Breakers Add-on Electrical Equipment The wiring circuits in your vehicle are protected from short circuits by fuses, circuit breakers and fusible NOTICE: thermal links in the wiring itself. This greatly reduces Don’t add anything electrical to your Geo unless the chance of fires caused by electrical problems.
Page 249 Windshield Wipers Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you The windshield wiper motor is protected by a circuit replace bad fuse with a new one of the correct size. breaker and a fuse.
Page 250 1. Not Used Driver’s Side Instrument Panel Fuse Block 2. Ignition 3. stop 4. Not UsedSpare 5. Cigarette Lighter and Radio 6. ECU-B 7. Turn Signal 8. Gage 9. Taillamp 10. Defogger I/UP 11. ECU-IG 12. Wiper A. Power B. Defroster 6-56...
Page 251 Engine Compartment Fuse Block I/UP 7. Left Head 8. Right Head 9. Not Used/Spare 10. Not UsedSpare 11. Not Used/Spare 12. AM2 A. Anti-Lock Brake System (ABS) B. Alternator C. AM1 A. Electronic Fuel Injection F/HTR Relay 1. Electronic Fuel Injection F/HTR B.
Page 252 Passenger Side Kick Panel Engine Compartment Relay Block 1. CDS Air Conditioner 2. Air Conditioner MG Relay Heater 3. Air Conditioner Fan Relay 4. Air Conditioner Fan Relay #2 6-58...
Page 253 Replacement Bulbs ............Rear Defogger Automatic Transaxle ............... Back-up 1156 StopLamp ............
Page 254 ... . Fuel Delivery Multi-Port Fuel Injection Spark Plug See your Chevrolet/Geo dealer Piston Displacement VIN Engine Code 6 ....Wheel Nuts (1.6L)
Page 255 Capacities (Approximate) ......The following approximate capacities are given in U.S. Fuel Tank 13.2 gal. (50 L) metric conversions..... Manual Transaxle 2.7 qt. (2.6 L)** ..Air Conditioning? See the refrigerant information See “Air Conditioning Refrigerants” later in this section. label under hood.
Page 256 Front 57.5” (1 460 refrigerant, be sure the proper refrigerant is used. If ......Rear 57.1” (1 450 you’re not sure, ask your Chevrolet/Geo dealer. For ......Length 173.0” (4 395 mm) additional information, see your “Warranty and Owner ......
Page 257 G e 4 B Section 7 Maintenance Schedule Introduction IMPORTANT: Your Vehicle and the Environment ENGINE OIL KEEP Proper vehicle maintenance not only helps to keep your AT THE PROPER LEVEL AND CHANGE AS vehicle in good worhng condition, but also helps the RECOMMENDED environment.
Page 258 Some of these “Part C: Periodic Maintenance Inspections” explains services can be complex, so unless you are technically important inspections that your Chevrolet/Geo dealer’s qualified and have the necessary equipment, you should service department or another qualified service center let your dealer’s service department or another qualified...
Page 259 Here’s how to decide which condition, see your Chevrolet/Geo dealer, schedule to follow: This part tells you the maintenance services you should have done and when you should schedule them. If you go to your dealer for your service needs, you’ll know...
Page 260 Maintenance Schedule Schedule I Intervals Schedule I Definition Every 15,000 Miles 000 km) Follow Maintenance Schedule I if any one of these is Air Cleaner Filter Inspection, if driving in dusty condition true for your vehicle: Transaxle Fluid Change (severe conditions only) Most trips are less than 5 to 10 miles (8 to 16 km).
Page 261 Maintenance Schedule Schedule I1 Definition Schedule I1 Intervals Miles (75 000 km) or 36 Months, Follow Schedule I1 only if none of the conditions from 45,000 Schedule I is true. Then Every 30,000 Miles Whichever Occurs First 000 km) or 24 Months Schedule I1 Intervals Cooling System Service Every 60,000 Miles (100 000 km)
Page 262 Maintenance Schedule I 3,000 Miles (5 000 km) Change engine oil and filter (or every The services shown in this schedule up to 100,000 miles (1 66 000 k m ) should be performed after 100,000 miles 3 months, whichever occurs first). (166 000 at the same intervals.
Page 263 Maintenance Schedule I 6,000 Miles (10 000 km) 7,500 Miles (12 500 km) Change engine oil and filter (or every Rotate tires. See “Tire Inspection and 3 months, whichever occurs first). Rotation” in the Index for proper rotation pattern and additional information. An Emission Control Service.
Page 264 Maintenance Schedule I 9,000 Miles (15 000 k t ) 12,000 Miles (20 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 3 months, whichever occurs first). 3 months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 265 Maintenance Schedule I 15,000 Miles (25 000 km) Change engine oil and filter (or every In hilly or mountainous terrain. 3 months, whichever occurs first). When doing frequent trailer towing. An Emission Control Service. Uses such as found in taxi, police or Inspect air cleaner filter if you are driving delivery service.
Page 266 Maintenance Schedule I 21,000 Miles (35 000 km) 18,000 Miles (30 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 3 months, whichever occurs first). 3 months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 267 Maintenance Schedule I 22,500 Miles (37 500 km) 24,000 Miles (40 000 km) Rotate tires. See “Tire Inspection and Change engine oil and filter (or every Rotation” in the Index for proper rotation 3 months, whichever occurs first). pattern and additional information? An Emission Control Service.
Page 268 Maintenance Schedule I 30,000 Miles (50 000 km) 27,000 Miles (45 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 3 months, whichever occurs first). 3 months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 269 Maintenance Schedule I Inspect fuel tank, cap and lines for damage In hilly or mountainous terrain. or leaks (or every 36 months, whichever - When doing frequent trailer towing. occurs first). Inspect fuel cap gasket for any - Uses such as found in taxi, police or damage.
Page 270 Maintenance Schedule I 33,000 Miles (55 000 km) 36,000 Miles (60 000 km) Change engine oil and filter (or every Change engine oil and filter (or every months, whichever occurs first). months, whichever occurs first). An Emissiun Control Service. An Emission Cuntrol Service. Lubricate the transaxle shift linkage, parking brake cable guides, underbody contact points and linkage (or every...
Page 271 Maintenance Schedule I 37,500 Miles (62 500 km) 39,000 Miles (65 000 km) Rotate tires. See “Tire Inspection and Change engine oil and filter (or every Rotation” in the Index for proper rotation 3 months, whichever occurs first). pattern and additional information. An Emission Control Service.
Page 272 W n G n a n c e Schedule I 42,000 Miles (70 000 km) 45,000 Miles (75 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 3 months, whichever occurs first). 3 months, whichever occurs first). An Emission Control Service.
Page 273 Maintenance Schedule I 48,000 Miles (80 000 km) - In hilly or mountainous terrain. Change engine oil and filter (or every 3 months, whichever occurs first). - When doing frequent trailer towing. An Emission Control Service. - Uses such as found in taxi, police or Lubricate the transaxle shift linkage, delivery service.
Page 274 Maintenance Schedule I 51,000 Miles (85 000 km) 52,500 Miles (87 500 km) Change engine oil and filter (or every Rotate tires. See “Tire Inspection and 3 months, whichever occurs first). Rotation” in the Index for proper rotation pattern and additional information. An Emission Control Service.
Page 275 Maintenance Schedule I 57,000 Miles (95 000 km) 54,000 Miles (90 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 3 months, whichever occurs first). 3 months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 276 Maintenance Schedule I 60,000 Miles (100 000 km) Change engine oil and filter (or ever! Adjl ust Val 7 b e cl earan ce to fa 3 months, whichever occurs first). specifications (or every 72 months whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 277 Maintenance Schedule I 63,000 Miles (105 000 km) Change fluid in the transaxle and Change engine oil and filter (or every differential every 15,000 miles (25 000 k m ) 3 months, whichever occurs first). if the vehicle is mainly driven under one or An Emission Control Service.
Page 278 Maintenance Schedule I 66,000 Miles (110 000 km) 67,500 Miles (112 500 km) Change engine oil and filter (or every Rotate tires. See “Tire Inspection and months, whichever occurs first). Rotation” in the Index for proper rotation pattern and additional information. An Emission Control Service.
Page 279 Maintenance Schedule I 69,000 Miles (115 000 km) 72,000 Miles (120 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 3 months, whichever occurs first). months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 280 Maintenance Schedule I 75,000 Miles (125 000 km) In hilly or mountainous terrain. Change engine oil and filter (or every months, whichever occurs first). When doing frequent trailer towing. An Emission Control Service. Uses such as found in taxi, police or Inspect air cleaner filter if you are driving delivery service.
Page 281 Maintenance Schedule I 78,000 Miles (130 000 k t ) 81,000 Miles (135 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 3 months, whichever occurs first). 3 months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 282 Maintenance Schedule I 84,000 Miles (140 000 km) 82,500 Miles (137 Change engine oil and filter (or every Rotate tires. See “Tire Inspection and 3 months, whichever occurs first). Rotation” in the Index for proper rotation pattern and additional information. An Emission Control Service.
Page 283 Maintenance Schedule I 87,000 Miles (145 000 km) 90,000 Miles (150 000 km) Change engine oil and filter (or every Change engine oil and filter (or every months, whichever occurs first). 3 months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 284 Maintenance Schedule I 000 km) (Continued) 90,000 Miles (150 In heavy city traffic where the outside Inspect fuel tank, cap and lines for damage temperature regularly reaches 90°F or leaks (or every 36 months, whichever (32°C) or higher. occurs first). Inspect fuel cap gasket for any damage.
Page 285 Maintenance Schedule I 93,000 Miles ( 1 5 5 000 km) 96,000 Miles (160 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 3 months, whichever occurs first). months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 286 Maintenance Schedule I 99,000 Miles (165 000 km) 97,500 Miles (162 500 km) Change engine oil and filter (or every Rotate tires. See “Tire Inspection and 3 months, whichever occurs first). Rotation” in the Index for proper rotation pattern and additional information. An Emission Control Service.
Page 287 Maintenance Schedule I1 7 , 5 0 0 Miles (12 500 km) Change engine oil and filter (or every The services shown in this schedule up to 100,000 miles (166 000 km) should be performed after 100,000 miles 12 months, whichever occurs first). (166 000 km) at the same intervals.
Page 288 Maintenance Schedule I1 15,000 Miles (25 000 km) In hilly or mountainous terrain. Change engine oil and filter (or every 12 months, whichever occurs first). When doing frequent trailer towing. An Emission Control Service. Uses such as found in taxi, police or Lubricate the transaxle shift linkage, delivery service.
Page 289 22,500 Miles (37 500 km) 30,000 Miles (50 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 12 months, whichever occurs first). 12 months, whichever occurs first). A n E177ission C m f d Service. An Emission Control Service.
Page 290 Schedule Maintenance 30,000 Miles (50 000 km) (Continued) - In hilly or mountainous terrain. Inspect fuel tank, cap and lines for damage or leaks (or every 36 months, whichever When doing frequent trailer towing. occurs first). Inspect fuel cap gasket for any Uses such as found in taxi, police or damage.
Page 291 Maintenance Schedule I1 37,500 Miles (62 500 km) 45,000 Miles (75 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 12 months, whichever occurs first). 12 months, whichever occurs first). An Emission Control Service. An Emission Control Service.
Page 292 Maintenance Schedule I1 52,500 Miles (87 500 km) 45,000 Miles (75 000 km) (Continued) - In hilly or mountainous terrain. Change engine oil and filter (or every 12 months, whichever occurs first). - When doing frequent trailer towing. An Emissiolz Control Service. Uses such as found in taxi, police or delivery service.
Page 293 Maintenance Schedule I1 60,000 Miles (100 000 km) Change engine oil and filter (or every Adjust valve clearance (or every 12 months, whichever occurs first). 72 months, whichever occurs first). An Emission Control Service. An Emission Control Service. Lubricate the transaxle shift linkage, Inspect evaporative emissions canister for parking brake cable guides, underbody damage or clogging (or every 72 months,...
Page 294 Maintenance Schedule I1 67,500 Miles (112 500 km) 60,000 Miles (100 000 km) (Continued) Change engine oil and filter (or every Change fluid in the transaxle and differential every 15,000 miles (25 000 km) 12 months, whichever occurs first). if the vehicle is mainly driven under one or An Emission Control Service.
Page 295 75,000 Miles (125 000 km) Change engine oil and filter (or every In hilly or mountainous terrain. 12 months, whichever occurs first). When doing frequent trailer towing. An Emission Control Service. Uses such as found in taxi, police or Lubricate the transaxle shift linkage, delivery service.
Page 296 82,500 Miles (137 500 km) 90,000 Miles (150 000 km) Change engine oil and filter (or every Change engine oil and filter (or every 12 months, whichever occurs first). 12 months, whichever occurs first). An Emission Control Service. An Emission Control Service. Lubricate the transaxle shift linkage, Lubricate the transaxle shift linkage, parking brake cable guides, underbody...
Page 297 Maintenance Schedule I1 Change fluid in the transaxle and Rotate tires. See “Tire Inspection and differential every 15,000 miles (25 000 km) Rotation’’ the Index for proper rotation if the vehicle is mainly driven under one or pattern and additional information. more of these conditions: - In heavy city traffic, where the outside temperature regularly reaches 90...
Page 298 Maintenance Schedule I1 Miles (162 500 km) 97,500 Inspect engine accessory drive belts (or Change engine oil and filter (or every 12 months since last inspection). 12 months, whichever occurs first). An Emission Control Service. An Emission Control Service. Lubricate the transaxle shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).
Page 299 Part B: Owner Checks and Services Engine Coolant Level Check the engine coolant level and add the proper Listed below are owner checks and services which coolant mix if necessary. See “Coolant” in the Index for should be performed at the intervals specified to help further details.
Page 300 At Least Once a Year At Least Once a Month Key Lock Cylinders Tire Inflation Lubricate the key lock cylinders with the lubricant Check tire inflation. Make sure tires are inflated to the specified in Part D. pressures specified on the Tire-Loading Information label located on the inside of the glove box door.
Page 301 Starter Switch Brake-Transaxle Shift Interlock BTSI (Automatic Transaxle) Before you start, be sure you have enough room around the vehicle. Before you start, be sure you have enough room around the vehicle. It should be parked on a level Firmly apply both the parking brake (see “Parking surface.
Page 302 Park on a fairly steep hill, with the vehicle facing Steering Column Lock downhill, Keeping your foot on the regular brake, set the While parked, and with the parking brake set, try to turn parking brake. the key to LOCK in each shift lever position. To check the parking brake: With the engine running With an automatic transaxle, the key should turn to and transaxle in NEUTRAL (N), slowly remove foot...
Page 303 Steering, Suspension and Part C: Periodic Maintenance Front-Wheel-Drive Axle Inspections Boot and Seal Inspection Listed below are inspections and services which should Inspect the front and rear suspension and steering be performed at least twice a year (for instance, each system for damaged, loose or missing parts, signs of spring and fall).
Page 304 The inspection listed below should be performed by and for damaged or missing parts. Replace parts as your Chevrolet/Geo dealer’s service department or some needed. Accelerator and cruise control cables should not other qualified service center. Make sure any necessary be lubricated.
Page 305 Part D: Recommended Fluids and USAGE FLUIDLUBRICANT Lubricants Hydraulic Clutch Hydraulic Clutch Fluid (GM Part System No. 12345347 or equivalent). NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your Power Steering DEXR0N’-I11 Automatic GM dealer.
Page 306 FLUID/LUBRICANT USAGE USAGE FLUID/LUBRICANT Lithium base grease. Hood and Door Engine oil or Lubriplate Lubricant Clutch Linkage (GM Part No. 1050109). Pivot Points Hinges, Fuel Door Hinge Floor Shift Engine oil. and Rear Linkage Compartment Lid Hinges Chassis Chassis lubricant (GM Part Lubrication No.
Page 307 Any additional information from “Owner Checks and Part E: Maintenance Record Services’’ or “Periodic Maintenance” can be added on After the scheduled services are performed, record the the following record pages. Also, you should retain all date, odometer reading and who performed the service maintenance receipts.
Page 308 Maintenance Record ODOMETER DATE MAINTENANCE PERFORMED SERVICED READING 7-52...
Page 309 Maintenance Record SERVICED BY MAINTENANCE PERFORMED 7-53...
Page 310 Maintenance Record ODOMETER DATE SERVICED BY READING MAINTENANCE PERFORMED 7-54...
Page 311 Maintenance R ODOMETER DATE SERVICED BY MAINTENANCE PERFORMED READING 7-55...
Page 312 Maintenance Record ODOMETER SERVICED READING DATE MAINTENANCE PERFORMED 7-56...
Page 313 Section 8 Customer Assistance Information Here you will find out how to contact Chevrolet/Geo if STEP ONE Discuss your concern with a member you need assistance. This section also tells you how to of dealership management. Normally, concerns can be obtain service publications and how to report any safety quickly resolved at that level.
Page 314 Customer Assistance Center. Any hearing or speech previously in order to give your inquiry prompt impaired customer who has access to a TDD or a attention. However, if you wish to write Chevrolet/Geo, conventional teletypewriter (TTY) can communicate write to: with Chevrolet/Geo by dialing: 1 -800-TDD-CHEV.
Page 315 BBB AUTO LINE Both Geo and your Chevrolet/Geo dealer are committed Council of Better Business Bureaus to making sure you are completely satisfied with your 4200 Wilson Boulevard new vehicle. Our experience has shown that, if a...
Page 316 BBB at any time. The BBB will attempt GOVERNMENT to resolve the complaint serving as an intermediary between you and Chevrolet/Geo. If this mediation is If you believe that your vehicle has a defect which could unsuccessful, an informal hearing will be scheduled...
Page 317 Transport Canada, in addition to notifying General Chevrolet Roadside Assistance Program Motors of Canada Limited. You may write to: To enhance Chevrolet’s strong commitment to customer Transport Canada satisfaction, Chevrolet has established the Box 8880 Chevrolet/Geo Roadside Assistance Center.
Page 318 Toll-free number, 1-800-CHEV-USA newer Chevrolet/Geo vehicles for a period of Free towing for warranty repairs 36 months/36,000 miles. All Courtesy Care services must be pre-arranged by Chevrolet Roadside or Dealer Basic over-the-phone technical advice Service Management. Available dealer services at reasonable costs...
Page 319 Courtesy Transportation will be offered in conjunction with the Chevrolet/Geo Courtesy Transportation is not part of coverage provided by the BUMPER TO BUMPER New the BUMPER TO BUMPER New Vehicle Limited Vehicle Limited Warranty to retail purchasers of 1995 Warranty.
Page 320 Service Bulletins Canadian Roadside Assistance Service bulletins covering various subjects are regularly Vehicles purchased Canada have an extensive sent to all General Motors’ dealerships. GM monitors Roadside Assistance program accessible from anywhere product performance in the field. When service methods in Canada or the United States.
Page 321 NOTES...
Page 322 NOTES 8-10...
Page 323 NOTES 8-11...
Page 324 NOTES 8-12...
Page 325 NOTES 8-13...
Page 326 NOTES 8-14...
Page 327 Section 9 Index ........A d d i n g Antenna 3-19...
Page 331 ......Express Down Window 2-25 Fuse Block. Driver’s Side Instrument Panel 6-56 .
Page 335 ........... . . Reclining Front Seatbacks Driver Position ....Recommended Fluids and Lubricants 7-49 .
Page 337 ............Inflation 6-38 Transaxle Fluid.

This manual is also suitable for:

Prizm 1995

Geo PRIZM 1995 Manual

Quick Links

Related Manuals for Geo PRIZM 1995

Summary of Contents for Geo PRIZM 1995

This manual is also suitable for: