Table of Contents
Advertisement
OWNER / OPERATOR MANUAL
WARNING
The engine exhaust from this product
contains chemicals known to the State
of California to cause cancer, birth
defects or other reproductive harm.
APPLICABLE SERIAL NUMBERS :
BACKPACK BLOWER
EB7000
010001 and up
Thank you for purchasing a RedMax
product.
Before using our blower, please read
this manual carefully to understand the
proper use of your unit.
T4012-93110 (005)
Advertisement
Table of Contents
Related Manuals for RedMax EB7000
Summary of Contents for RedMax EB7000
- Page 1 California to cause cancer, birth defects or other reproductive harm. APPLICABLE SERIAL NUMBERS : EB7000 Thank you for purchasing a RedMax product. Before using our blower, please read this manual carefully to understand the proper use of your unit.
-
Page 2: Safety First
Instructions contained in warnings within this manual and warning seals marked with a symbol on the blower concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail. -
Page 3: Table Of Contents
SAFETY PRECAUTIONS·······························································4 OPERATOR USE OF BLOWER FUEL WORKING CONDITION AVOID NOISE PROBLEM AVOID CHANCES OF DAMAGE WARNING LABELS ON THE MACHINE·······································7 SYMBOLS ON THE MACHINE······················································8 PARTS LOCATION & SPECIFICATIONS ······································9 ASSEMBLY ····················································································9 BLOWER TUBE FUEL·····························································································10 HOW TO MIX FUEL FUELING THE UNIT OPERATION ·················································································11... -
Page 4: Safety Precautions
OPERATOR • Refrain from operating the blower if you are tired, ill, or upset, or if you are under the influence of alcohol, drugs or medication. • To reduce the risk of hearing loss associated with sound level(s), hearing protection is required. -
Page 5: Fuel
• Avoid using any accessory or attachment other than those bearing the RedMax mark for use with the blower. • Drain the fuel from the fuel tank before transporting or storing the blower. -
Page 6: Avoid Noise Problem
• Watch out for children, pets, open windows or freshly washed cars, and blow debris safely away. • Use the full blower nozzle extension so the air stream can work close to the ground. • After using blowers and other equipment, CLEAN UP! Dispose of debris in trash receptacles. -
Page 7: Warning Labels On The Machine
(2) Wear head, eye and ear protection. (3) Handling this machine improperly could result in accidents causing serious injury or death. Read this manual carefully and practice using the blower until you are fully acquainted with all operations and have learned to use it correctly. -
Page 8: Symbols On The Machine
ENGINE DISPLACEMENT : 62.0cc REFER TO OWNER'S MANUMAL FOR MAINTE- NANCE SPECIFICATIONS AND ADJUSTMENTS. RedMax For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to take a mistake. -
Page 9: Parts Location & Specifications
Parts Location & Specifications Shoulder Strap Frame Stop Switch (Behind) Throttle Lever MODEL EB7000 Dimensions ( L x W x H ) Dry Weight Fuel Tank Capacity Engine Type Piston Displacement Air Filter Carburetor ( Diaphragm ) Ignition System Spark Plug... -
Page 10: Fuel
3m(10ft) away from the fueling point before starting the engine. • The RedMax engines are lubricated by oil specially formulated for air-cooled 2-cycle gasoline engine use. If RedMax oil is not available, use an anti-oxidant added quality oil expressly labeled for air-cooled 2-cycle engine use. -
Page 11: Operation
Pump 3.Set the throttle lever in 1/3 open position. Full Throttle 4.To start, hold the top of the blower firmly with your left hand. Pull the starter knob slowly until you feel it engage and then give it a vigorous strong pull. -
Page 12: Adjusting Idle Speed
Operation the choke if it was set closed, and let the engine run at idle speed for a minute to warm it up. NOTE • When the engine fails to start after several attempts due to overchoking, open the choke and repeat pulling the rope. ADJUSTING IDLE SPEED •... -
Page 13: Maintenance
• Make sure that the engine has stopped and is cool before performing any service to the blower. Contact with rotating blower fan or hot muffler may result in a personal injury. AIR CLEANER • C h e c k the air cleaner every once week of use or more frequently if used under dusty conditions. -
Page 14: Muffler
• Note that failure to remove any such obstacles may result in the engine becoming overheated and damaged. WARNING • Never use the blower without the net of the blower. Before each use, check that the net is attached in place and is free from any damage. -
Page 15: Shoulder Strap
Maintenance SHOULDER STRAP • If the shoulder strap is damaged it may break during use, thus causing the product to fall and resulting in personal injury. Follow the instructions below to replace the shoulder strap. • Pass the upper end of the strap through the hanger, making the FLAPPED SIDE OUTSIDE. -
Page 16: Storage
Storage BEFORE STORING THE BLOWER: 1.Drain a fuel tank and push the primer bulb until it becomes empty of fuel. 2.Remove the spark plug and drop a spoonful of 2-cycle oil into the cylider. Crank the engine several time and replace... -
Page 17: Parts List
(7) years after the machine is discontinued. It is also possible that some parts may be available even after the limit of seven (7) years.] APPLICABLE SERIAL NUMBERS : EB7000 010001 and up... - Page 18 EB7000 Fig.1 BLOWER GROUP (S/N 010001 and up)
- Page 19 EB7000 Fig.1 BLOWER GROUP Key# Part Number Description 2750-31111 VOLUTE CASE 2750-31211 VOLUTE COVER 2750-31150 SCREW M5x25 3490-11150 ELBOW 07000-02095 O-RING 2750-31420 SCREW M5x70 3310-53331 T4012-31310 COVER INLET 2750-31150 SCREW M5x25 1140-72231 CLAMP 3407-16120 SCREW M5x14 2750-31290 TUBE 2750-31911 LABEL...
- Page 20 Parts List : EB7000 Fig.2 ENGINE GROUP (S/N 010001 and up)
- Page 21 EB7000 Fig.2 ENGINE GROUP Key# Part Number Description 2750-12110 CYLINDER 2750-12210 GASKET, base 1850-12130 BOLT 1484-13160 INSULATOR 2750-13130 GASKET 1460-13132 GASKET 0263-90535 SCREW 2750-12510 COVER 2750-12520 BOLT 2756-15100 MUFFLER ASS’Y 1421-15120 • ARRESTER 2750-15210 GASKET 2750-15160 BOLT 2750-15170 BOLT 2750-21100...
- Page 22 Parts List : EB7000 Fig.3 CARBURETOR COMPONENTS Fig.3 CARBURETOR COMPONENTS Key# Part Number Description 5602-06030 REBAILT KIT 1850-81450 • BODY ASS’Y ————— • • SCREEN ————— • • VALVE ————— • • SPRING ————— • • SCREW ————— • • PIN —————...
- Page 24 CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and KOMATSU ZENOAH are pleased to explain the emission control system warranty on your 1995 and later small off-road engine. In California, new small off-road engines must be designed, built and equipped to meet the state’s stringent anti-smog standards.
- Page 25 ZENOAH AMERICA INC. AT (770)-381-5147. IMPORTANT: YOU WILL RECEIVE A WARRANTY REGISTRATION CARD AT TIME OF PURCHASE.PLEASE FILL OUT THE CARD AND SEND IT TO RedMax / KOMATSU ZENOA AMERICA WITHIN SEVEN (7) DAYS.BE SURE TO KEEP A COPY FOR YOUR RECORDS.
- Page 26 (2) ans à compter de la date initiale de livraison d’une unité du modèle EB7000. Les pièces en rapport avec les émissions de gaz d'échappement sont: l'assemblage carburateur, l'assemblage bobine, le rotor, la bougie, le filtre à...
- Page 28 KOMATSU ZENOAH AMERICA INC. 4344 Shackleford Road Suite 500 Norcross, Georgia 30093...