Weber Genesis Silver B A205_LP.c Owner's Manual

Lp gas grill

Advertisement

Y
OU MUST READ THIS
BEFORE OPERATING YOUR GAS GRILL
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING
1. Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2. Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if
the barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
WARNING: Do not try to light this
appliance without reading the "Lighting"
Instructions section of this manual
G E N E S I S
O
G
WNERS
UIDE
DANGER
®
LP Gas Grill Owners Guide
#
A205_LP.c
Ba201.c
B201_LP.b
C201_LP.c
D201_LP.c
E201.c
55276 01/28/02
Cast Iron LP
US English

Advertisement

Table of Contents
loading

Summary of Contents for Weber Genesis Silver B A205_LP.c

  • Page 1 WARNING: Do not try to light this appliance without reading the “Lighting” Instructions section of this manual G E N E S I S LP Gas Grill Owners Guide WNERS UIDE A205_LP.c Ba201.c B201_LP.b C201_LP.c D201_LP.c E201.c ® 55276 01/28/02...
  • Page 2: Danger & Warnings

    Should the burners go out while in operation, turn all gas valves off. Open the lid and wait five minutes before attempting to relight, using the lighting instructions. Do not use charcoal or lava rock in your Weber Never lean over open grill or place hands or fingers on the front edge of the cooking box.
  • Page 3: Table Of Contents

    Contents Danger & Warnings ...A-2 Warranty ...A-4 General Instructions ...A-5 Cooking ...A-6 Cleaning ...A-6 Cast Iron Cooking Grates Care Instructions Exploded View ...A-8 Parts List ...A-10 Unpacking ...A-11 Assembly Instructions ...B-a Gas Instructions ...C-1 Leak Checking ...C-3 Refilling the LP Cylinder ...C-4 Safe handling tips for LP Gas ...C-5...
  • Page 4: Warranty

    ® will attached to the cylinder. If the cylinder manufacturer has not resolved the issue to your satisfaction, then call Weber- Stephen Products Co., Customer Service Center. is not liable for any special, indirect or does not authorize any person or company to...
  • Page 5: General Instructions

    National Fuel Gas Code: ANSI Z 223.1. • The pressure regulator supplied with the Weber barbecue must be used. This regulator is set for 10.5 inches of water column (pressure).
  • Page 6: Cooking

    Cooking WARNING: Do not move the Weber when operating or while barbecue is hot. You can adjust the FRONT and BACK burners as desired. The control settings: High (H), Medium (M), Low (L), or Off ® (O) are described in your Weber cookbook.
  • Page 7: Cast Iron Cooking Grates Care Instructions

    Cast Iron Cooking Grates Care Instructions WARNING: Follow all safety instructions provided with your barbecue. Do not drop cast iron grates, they will break. First Time Use - Wash thoroughly with a mild dishwashing liquid to remove the wax coating used for protection in shipping.
  • Page 8: Exploded View

    Exploded View ® Genesis Silver-B LP 092801...
  • Page 9: Exploded View List

    Hinge Pin Left Endcap Shroud Handle ™ Warm-Up Basket Warming Rack Cast Iron Cooking Grates ® Flavorizer Bars Cooking Box 1/4-20 keps nut Slide Out Bottom Tray Work Surface Catch Pan Holder Left Rear Trim Assembly Arm 1/4 - 14 x 5/8 inch bolt Left Trim Piece Left Front Trim Assembly Arm 1/4 - 20 x 2 inch bolt...
  • Page 10: Parts List

    Cooking Box Assembly - 1 Caster Frame - 1 Wheel Frame - 1 Bottom Rack - 1 Left Trim Assembly - 1 Swing Up Table - 1 Side Table - 1 Parts List Right Trim Piece - 1 Frame Plug - 1 Flavorizer ®...
  • Page 11: Unpacking

    Unpacking A-11...
  • Page 12 • Arrow sticker to the front. • Push down firmly until Bottom Rack Lock, "locks" under the rail. Ba201.c...
  • Page 13 • Push down firmly on both sides to ensure bottom rack is locked under the rails. WARNING: Do not go to next step if bottom rack is not locked in place...
  • Page 14 • Install bolts at indicated locations. Use supplied tool to tighten. Recheck each bolt for tightness with a 7/16” open end wrench.
  • Page 15 B201_LP.b...
  • Page 21: Gas Instructions

    NEVER store a spare LP Cylinder under or near this barbecue. NEVER fill the tank beyond 80% full. ® Your Weber gas grill is equipped with a cylinder supply system designed for vapor withdrawal. WARNING: Only use this grill outdoors in a well- ventilated area.
  • Page 22 You will need: LP cylinder, a soap and water solution and a rag or brush to apply it. 1) Turn the LP cylinder so the opening of the valve is either to the front, side or rear of the Weber barbecue. Lift and hook the cylinder onto the fuel gauge.
  • Page 23: Leak Checking

    Note - All factory-made connections have been thoroughly checked for gas leaks. The burners have been flame tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber barbecue. Shipping and handling may have loosened or damaged a gas fitting.
  • Page 24: Refilling The Liquid Propane Cylinder

    Check: 1) Hose-to-manifold connection. 2) Regulator-to-Cylinder connection. WARNING: If there is a leak at connection (1), retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas.
  • Page 25: Safe Handling Tips For Liquid Propane Gas Cylinders

    American Gas Association, and Underwriters Laboratories requirements. Liquid Propane Cylinder requirements Replacement LP cylinders supplied by Weber satisfy the above requirements. Check to be sure other cylinders have a D.O.T. certification(1), and date tested(2) is within five years. Your LP gas supplier can do this for you.
  • Page 26: Operating Instructions

    WARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual.
  • Page 27: Manual Lighting

    Manual Lighting DANGER Failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 1) Open the lid.
  • Page 28: Troubleshooting

    If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your region using the contact information sheet provided with your manual. Troubleshooting Check Inspect Weber ® Insect / Spider screens for possible instructions. (Blockage of holes.)
  • Page 29: Maintenance

    Lightly tap the burner to get debris and dirt out of the burner tube. Once the spider/insect screens and burners are clean replace the burners. If the spider/insect screen becomes damaged or cannot be cleaned, call Weber-Stephen Products Customer Service for replacement parts. Main Burner Flame Pattern The Weber ®...
  • Page 30: Replacing Main Burners

    Replacing Main Burners 1) Your Weber ® gas barbecue must be OFF and cool. 2) Turn gas OFF at source. 3) To remove control panel: take off the burner control knobs. Remove the screws holding the control panel in place. Lift off the control panel.

Table of Contents