Weber Summit Gas Grill S-460 Owner's Manual
Built-in lp gas grill
Hide thumbs
Also See for Summit Gas Grill S-460:
- Owner's manual (215 pages) ,
- Installation manual (25 pages) ,
- Owner's manual (32 pages)
Table of Contents
Advertisement
GAS GRILL
Built-In LP Gas Grill Owner's Guide
™
S-460
- LP
YOU MUST READ THIS OWNER'S GUIDE
BEFORE OPERATING YOUR GAS GRILL
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING:
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
#43255
#00000
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
WARNING: Do not try to light this
appliance without reading the "Lighting
Instructions" section of this manual.
43255 US 08/06/08
LP
US ENGLISH
Advertisement
Table of Contents
Related Manuals for Weber Summit Gas Grill S-460
Summary of Contents for Weber Summit Gas Grill S-460
- Page 1 GAS GRILL Built-In LP Gas Grill Owner’s Guide ™ S-460 - LP YOU MUST READ THIS OWNER’S GUIDE BEFORE OPERATING YOUR GAS GRILL DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3.
- Page 2 Do not use a flame to check for gas leaks. Combustible materials should never be within 24 inches (61 cm) of the back or sides of your Weber Do not put a barbecue cover or anything flammable on, or in the storage area under the barbecue.
-
Page 3: Shroud
Weber does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or replacement of its equipment; and no such representations are binding on Weber. - Page 4 EXPLODED VIEW S-460 S460_LP_US WWW.WEBER.COM ®...
-
Page 5: Table Of Contents
Control Panel Wiring Harness Manifold Control Panel Small Knob Bezel Small Knob Large Knob Large Knob Bezel Sear Station Knob WWW.WEBER.COM ® EXPLODED VIEW LIST S-460 Battery Housing Water Baffle / Heat Shield Disposable Drip Pan Drip Tray Catch Pan Catch Pan Holder... - Page 6 GENERAL INSTRUCTIONS STORAGE AND/OR NONUSE • The gas must be turned off at the liquid propane cylinder when the Weber barbecue is not in use. • LP cylinder must be stored outdoors in a well-ventilated area out of reach of children.
-
Page 7: Thermometer
DANGER NEVER store a spare LP Cylinder under or near this barbecue. NEVER fill the tank beyond 80% full. Your Weber ® gas grill is equipped for a cylinder supply system designed for vapor withdrawal. WARNING: Only use this grill outdoors in a well-ventilated area. - Page 8 One series of tanks mount with the valve facing front (a). The other tanks mount with the valve facing away from the fuel scale (b). Weber recommends the use of cylinder manufacturer’s Manchester and Worthington, with a 47.6 lb water capacity.
- Page 9 Note: All factory-made connections have been thoroughly checked for gas leaks. The burners have been flame-tested. As a safety precaution however, you should recheck ® all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may loosen or damage a gas fitting.
- Page 10 If a leak persists after re-tightening the fitting, turn off the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com Hose to regulator connection. Regulator to cylinder connection.
-
Page 11: Gas Instructions
This vent should be free of dirt, grease, bugs etc. • The gas connections supplied with your Weber designed and tested to meet 100% CSA and ANSI requirements. WARNING: Replacement LP tanks must match the regulator connection supplied with this barbecue. - Page 12 WARNING: If the burner still does not light, turn the burner control knob to “OFF” and wait 5 minutes to let the gas clear before you try again or try to light with a match. GAS INSTRUCTIONS WWW.WEBER.COM ®...
- Page 13 If the hose is found to be damaged in any way, do not use the barbecue. Replace ® using only Weber authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site.
-
Page 14: Grilling Methods
YOU control the flames. Because of the special design of the Flavorizer directed through the funnel-shaped bottom tray into the grease catch pan. START/ MED. ® bars, ® bars and the flexible temperature controls, ® bars and burners, excess fats are WWW.WEBER.COM ®... -
Page 15: Handle
Foods on a crowded cooking grate will require more cooking time than just a few foods. Foods grilled in containers, such as baked beans, will require more time if grilled in a deep casserole rather than a shallow baking pan. WWW.WEBER.COM ® OPERATING INSTRUCTIONS •... - Page 16 WARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber ® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site.
- Page 17 Note: See Maintenance for burner removal and cleaning procedure. TO EXTINGUISH Push in and turn each burner control knob clockwise to “OFF” position. Turn gas supply off at the source. WWW.WEBER.COM ® OPERATING INSTRUCTIONS ARRÊTÉ APAGADO * The grill illustrated may have slight differences than the model purchased.
- Page 18 To a lesser degree a “smoke” residue will accumulate on the inside of your gas grill. This residue need not be removed and will not adversely affect the function of your gas grill. EN MARCHE ENCENDIDO WWW.WEBER.COM ®...
- Page 19 ® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com Open the grill lid. Open smoker box lid. Fill smoker with water soaked wood chunks or chips.
- Page 20 Weber ® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com Open the lid. DANGER Failure to open the lid while igniting the grill, or not waiting...
-
Page 21: Rotisserie Motor
Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com 2) Slide one of the spit forks towards the right side of the rotisserie shaft, making sure that the spikes face to the left and the fork screw faces down. -
Page 22: Flavorizer ® Bars
WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only a Weber ® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. - Page 23 Finish cooking on indirect heat. TO EXTINGUISH Push in and turn each burner control knob clockwise to “OFF” position. Turn gas supply off at the source. WWW.WEBER.COM ® OPERATING INSTRUCTIONS * The grill illustrated may have slight...
- Page 24 WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only a Weber ® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site.
-
Page 25: Burner Tubes
OPERATING THE HANDLE LIGHT The Weber Grill Out™ Handle Light has a built-in “Tilt Sensor.” With the power button (a) activated, the light will come on when the grill lid is open. The light will turn off when the lid is closed. - Page 26 If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® WEBER ®...
-
Page 27: Manifold
REMOVE CONTROL PANEL Part required: Phillips Screwdriver. Remove the burner control knobs. Remove the two screws that secure the control panel to the frame. Remove the control panel. Tilt panel forward and lift up and away from grill. WWW.WEBER.COM ® MAINTENANCE... - Page 28 Check proper assembly before fastening manifold in place. WARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the grill. (See, “Check for gas leaks.”) MAINTENANCE WWW.WEBER.COM ®...
- Page 29 Insect screens and burners are clean replace the burners. If the Spider/Insect screen becomes damaged or cannot be cleaned, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® BURNER FLAME PATTERN The Weber ®...
- Page 30 ©2008 The following trademarks are registered in the name of Weber-Stephen Products Co., an Illinois corporation, located at 200 East Daniels Road, Palatine, Illinois 60067 U.S.A. Australia; Smokey Joe, Weber, Kettle Silhouette , Genesis, Austria; Kettle Silhouette , Smokey Joe, Weber, Benelux; Kettle Silhouette , Smokey Joe, Weber, Compact Grill Configura- tion, Botswana;...
- Page 31 (If you register online, you do not need to send in this registration card.) Para registrar el producto, llene y envíe por correo este formulario o REGÍSTRESE EN LÍNEA en www.weber.com Para registrar el producto, llene y envíe por correo este formulario o REGÍSTRESE EN LÍNEA en www.weber.com (Si se registra en linea, no necesita enviar esta tarjeta de registro).
- Page 32 Knowing more about who buys our grills helps the crew back in R&D come up with new cutting edge Weber products. Please fill in the answers you feel comfortable sharing with us, and pass by any question you prefer to leave blank.