Summary of Contents for Blue Rhino Endless Summer 81000
Page 1
Owner’s Manual Model No. 81000 WARNING FOR YOUR SAFETY: For Outdoor Use Only (outside any enclosure) Solamente Para Uso En Exteriores (fuera de cualquier recinto) WARNING FOR YOUR SAFETY: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.
ANSI/NFPA 58 or CSA B149.1, Natural Gas and Propane Installation Code. Save these instructions for future reference. If you are assembling this unit for someone else, give this manual to him or her to save for future reference. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
Notice: This product should not be used with any fuel other than liquid propane. Use of other fuels will detract from heaters performance and will void your warranty. Owner’s manual and assembly instructions: 81000 portable outdoor heater Before you do anything else, read and understand all...
Page 4
Note: When using a 20 lb. Cylinder, it is necessary to use the special hose adaptor provided for this connection. This adapter is supplied with a type POL connecter at the cylinder connection end. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
Contact 1-800-762-1142 for assistance. Do not return to place of purchase. Components Owner’s manual and assembly instructions: 81000 portable outdoor heater Finial Dome Cap Dome Top Wire Guard Emitter Assembly Bottom Wire Guard Post Shroud Cover Housing Access Panel Plastic Ring...
Step 1 – Attach Emitter Screen • Line up 4 holes on bottom of Emitter Screen with corresponding holes in Emitter Bottom, and insert (4) Medium Screws in holes until tight. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
• Lay Dome Cap on Dome covering 3 Nuts and line up center holes. • Insert threaded end of Finial through Cap and screw into center of Dome until secure. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
• Line up threads on canister with those on regulator, insert and rotate canister clockwise until they fit snugly together. HAND TIGHTEN ONLY. BE CAREFUL NOT TO CROSS THREADS WHEN SCREWING IN CANISTER. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
• Slide top tab of Access Panel inside Shroud Cover. • Lower bottom of Panel until closed, and rotate Knob until lock flange rotates inside of slot on plastic ring. Owner’s manual and assembly instructions: 81000 portable outdoor heater Caution: Your Endless Summer Portable Heater has been checked at all factory connections for leaks.
(not provided) to secure your cylinder. Note: Once you have read “safety first” and successfully completed Steps 1 – 9, you are ready to begin operating your heater. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
6. Replace Access Panel. If you experience any ignition problem, turn off the heater and gas supply, and consult “Troubleshooting” on page 13. Owner’s manual and assembly instructions: 81000 portable outdoor heater WARNINGS FOR YOUR SAFETY: Do NOT attempt to operate •...
2. Turn off gas at cylinder. 3. Remove Access Panel. 4. Unscrew gas line from regulator. 5. Close Access Panel. Note: After use, some discoloration of the emitter screen is normal. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
After Operation Gas control is in OFF position. Gas tank valve is OFF Disconnect Gas line. Heater is upright in a secure location. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
Base is not on a level surface Heater is level Dirt or film on reflector and emitter Blockage in burner Owner’s manual and assembly instructions: 81000 portable outdoor heater Then do this Replace cylinder or canister Clear blockage Clean venturi...
Use high-quality automobile wax to help maintain the appearance of your heater. Apply to exterior surfaces from the pole down. Do not apply to emitter screen, dome, or wire guard. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
Use only original equipment replacement parts. Use of unauthorized parts or modification of parts will void warranty and create an unsafe condition. Caution: Always allow heater to cool before attempting service. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
Heater’s warranty extends for 2 years from date of purchase by original purchaser. Warranty Terms Manufactured by Blue Rhino Global Sourcing 104 Cambridge Plaza Drive, Winston-Salem, NC 27104. 1-800-762-1142. Manufacturer will cover: All parts found to be defective due to materials or workmanship for 2 years from the date of original purchase.
Manifold Pressure: 11.00 in. W.C. Supply Pressure: 0.41 psig (11.00 in. W.C.) Engine: IPP E8 Safety Features: 100% Burner shut-off Tilt Switch Manufacturer: Blue Rhino Global Sourcing Made In: China Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...
Page 19
Contact 1-800-762-1142 for assistance. Do not return to place of purchase. Owner’s manual and assembly instructions: 81000 portable outdoor heater 3/3/03...