Checking/Adding Fuel; Check/ Change Transmission Oil; Regular Maintenance - Simplicity Broadmoor 16HP V-Twin Operator's Manual

Regular Maintenance

A
WARNING
Gasoline is highly flammable and must be
handled with care. Never fill the tank when the
engine is still hot from recent operation. Do not
allow open flame, smoking or matches in the
area. Avoid over-filling and wipe up any spills.
Do not remove fuel filter when engine is hot, as
spilled gasoline may ignite. DO NOT spread hose
clamps further than necessary. Ensure clamps
grip hoses firmly over filter after installation.
CHECKING /ADDING FUEL
To add fuel:
1. Remove the fuel cap (see A, Figure 15).
2. Fill the tank. Do not overfill. Leave room in the tank
for fuel expansion. Refer to your engine manual for
specific fuel recommendations.
3. Install and hand tighten the fuel cap.
CHECK/ CHANGE
TRANSMISSION OIL
The transmission oil should be checked before each use
and changed after the first 50 hours of operation. Then
change the oil after every 250 hours of operation. The
oil should also be changed if it has become discolored
from overheating or contamination.
Transmission Oil Capacity: Apx. 3.5 Quarts
Transmission Oil Type: SAE low-30 with a minimum
API rating of SG/CD.
Do not allow dirt, water, or other debris to
enter the reservoir. Even a small amount of
dirt can irreparably damage the transmission
Checking the Oil Level:
.
Observe the oil level. Oil should be up to the FULL
mark (see Figure 16). DO NOT OVERFILL. Empty
space is required in the reservoir tank for heat expan-
sion.
cap, remove the cap, and add oil.
Changing the Transmission Oil:
Figure 17). Drain oil into a suitable container.
2. Reinstall the drain plug.
3. Add oil a few ounces at a time until the reservoir is
filled to the FULL mark. DO NOT OVERFILL. Empty
space is required in the reservoir tank for heat expan-
sion.
4. Run tractor for several minutes and recheck the
transmission oil level.
Figure 15. Fuel Tank Fill
A. Fuel Tank Cap.
Do not use gasoline containing METHANOL,
gasohol containing more than
10% ETHANOL, gasoline additives, or white
gas because engine/fuel system damage
could result.
Figure 16. Transmission Oil Reservoir
Figure 17. Transmission Drain Plugs
1 6