Page 1
IMPORTANT MANUAL OPERATOR'S MANUAL MODEL: PB195H42LT LAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 411287 12.19.06 TH Do Not Throw Away 02478 WARNING: Read this Man u al and follow all Warnings and Safety Instructions. Fail ure to do so can re sult in serious in ju ry.
Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. WARNING: In order to prevent ac ci - den tal starting when setting up, trans- port ing, ad just ing or making repairs, al ways dis con nect spark plug wire...
Page 3
Safe Operation Practices for Ride-On Mowers III. CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the ma chine and the mowing activity. Never assume that children will remain where you last saw them. •...
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness. TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier.
Page 7
• Push down on seat to engage pads in slots and pull seat towards rear of tractor. • Raise seat and tighten bolt securely. • Remove tape and discard. • Lower seat into operating position and sit on seat. Press clutch/brake pedal all the way down. If operating position is not comfortable, adjust seat.
Page 8
CHECK TIRE PRESSURE The tires on your tractor were overinflated at the factory for shipping purposes. Correct tire pressure is important for best cutting performance. • Reduce tire pressure to PSI shown on tires. CHECK DECK LEVELNESS For best cutting results, mower housing should be properly leveled.
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean- ing. REVERSE NEUTRAL REVERSE ENGINE ON ENGINE OFF OPERATION SYSTEM (ROS) OIL PRESSURE FUEL OVER TEMP LIGHT ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED LIGHTS ON FREE WHEEL...
Page 10
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. THROTTLE/CHOKE CONTROL PARKING BRAKE...
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safety glass es or eye shields while operating your tractor or per form ing any adjustments or repairs. We rec om mend a wide vision safety mask over spectacles or stan dard safety glasses.
Page 12
The cutting height range is ap prox i mate ly 1" to 4". The heights are measured from the ground to the blade tip with the engine not running. These heights are approximate and may vary depending upon soil conditions, height of grass and types of grass being mowed.
TO TRANSPORT When pushing or towing your tractor, be sure to disengage transmission by placing freewheel control in free wheel ing po si tion. Free wheel control is located at the rear drawbar of tractor. • Raise attachment lift to highest position with at tach ment lift control.
Page 14
COLD WEATHER STARTING ( 50° F and below) • When engine starts, allow engine to run with the throttle control in the choke position until the engine runs roughly, then move throttle control to fast posi- tion. This may require an engine warm-up period from several seconds to several minutes, depending on the tem per a ture.
TRACTOR Always observe safety rules when per form ing any main- te nance. BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in high est gear on a level, dry concrete or paved surface, then brake must be checked and ad just ed. (See “TO ADJUST BRAKE”...
Page 17
• Slide blade on to an unthreaded portion of the steel bolt or pin and hold the bolt or pin parallel with the ground. If blade is balanced, it should remain in a horizontal position. If either end of the blade moves downward, sharpen the heavy end until the blade is balanced.
CLEAN AIR SCREEN Air screen must be kept free of dirt and chaff to prevent engine dam age from overheating. Clean with a wire brush or com pressed air to re move dirt and stubborn dried gum fibers. AIR FILTER Your engine will not run properly using a dirty air filter.
SERVICE AND ADJUSTMENTS WARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUST- MENTS: • Depress clutch/brake pedal fully and set parking brake. • Place motion control lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. •...
Page 20
SERVICE AND ADJUSTMENTS FIG. 16 • ATTACH REAR LIFT LINKS (C) - Lift rear corner of mower and position slot in link assembly over pin (D) on rear mower bracket and secure with washer and retainer spring. FIG. 17 • ATTACH FRONT LINK (E) - Work from left side of trac- tor.
Page 21
SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn and lead you to think the mower is not adjusted properly.
SERVICE AND ADJUSTMENTS To Replace Mower Drive Belt (See Fig. 24) MOWER DRIVE BELT REMOVAL 1. Park tractor on a level surface. En gage parking brake. 2. Lower attachment lift lever to its lowest position. 3. Remove any dirt or grass clippings which may have accumulated around mandrels and entire upper deck surface.
Page 23
SERVICE AND ADJUSTMENTS TRANSAXLE MOTION CONTROL LEVER NEUTRAL ADJUSTMENT (See Fig. 26) The motion control lever has been pre set at the factory and adjustment should not be necessary. • Loosen adjustment bolt in front of the right rear wheel, and lightly tighten.
SERVICE AND ADJUSTMENTS WEAK OR DEAD FULLY CHARGED BATTERY BATTERY FIG. 28 REPLACING BATTERY ( See Figs. 29 and 30 WARNING: Do not short battery ter mi nals by allowing a wrench or any other object to contact both terminals at the same time.
Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open flame or spark.
TROUBLESHOOTING POINTS PROBLEM CAUSE Will not start Out of fuel. Engine not “CHOKED” properly. Engine flooded. Bad spark plug. Dirty air filter. Dirty fuel filter. Water in fuel. Loose or damaged wiring. Carburetor out of adjustment. Engine valves out of adjustment. Hard to start Dirty air filter.
Page 27
TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when Reverse operation system tractor is shifted (ROS) is not "ON" while into reverse mower or other attachment is engaged. Engine continues to run Faulty operator-safety presence control system. when operator leaves seat with attachment clutch engaged Poor cut - uneven Worn, bent or loose blade.
In the event you have a claim under this Warranty, you must return the product to an authorized service dealer. Should you have any unanswered questions concerning this Warranty, please contact: Poulan Pro Outdoor Products Customer Service Dept. 1030 Stevens Creek Road...
Page 37
à endroit d’un droits d’autres à s’appliquent ci-dessus énoncées durée conséquents dommages GARANTIES POUR PRÉCISÉES INCIDENTEL DOMMAGE Mississauga, Terry 5855 Poulan Dept. Service Canada: machine votre d’achat date série, plaît vous s’il garantie, cette concernant veuillez-vous garantie, cette garantie. normal, l’usage...
Page 38
moteur. avant lent) rapide (entre intermédiaire position dans commande l’alternateur. régulateur. connexions. toutes Vérifiez/remplacez batterie. fusible. connexions. câblage phares. l’interrupteur Vérifiez/remplacez lampe(s). l'ampoule(s) (ON). marche position à l’interrupteur trous ouvrir pour mandrin faces manuel. recomman- lames avec lames tranchant bord avec lames d’entraînement...
Page 39
endommagées. pièces Remplacez lâches. pièces lame. mandrin lame. boulon fond à Serrez lame. autorisé. d’entretien centre Réglages. Entretien dans Carburateur” Régler “Pour section câblage. tout silencieux. Nettoyez/remplacez moteur/ailettes. d’air tamis d’allumage. bougie serrez d’essence. filtre fraîche, l’essence avec réservoir carburateur, réservoir l’essence fraîche.
Page 40
SONT D’ÉCHAPPEMENT ENDROITS QUAND TRACTEUR JAMAIS COUVREZ tracteur. condensation formation permet obstrue plastique plastique. N’uti perméable. couverture avec saleté. poussière couvrez-le possible, l’intérieur, à tracteur causera l’essence dans saleté et/ou rouiller. à commence s’il d’essence l’autre. à saison d’une d’essence SUPPLÉMENTAIRE d’allumage.
Page 41
FIG. PHARES CÂBLES CONNECTEUR CAPOT ci-dessus. étapes inversez tracteur. moteur vers inclinez-le latéraux, capot Empoignez tracteur. devant phares. câbles connecteur Fig. CAPOT bleau derrière ment situé automobile, type enfichable fusible FUSIBLE REMPLACER Rechange. Pièces électrique câblage schéma Voir tracteur. non-démarrage l'arrêt mauvais cause...
Page 42
batteries. deux ROUGE câble complètement. chargée batterie châssis NOIR câble premièrement RENVERSEZ CÂBLES, d’es réservoir loin câbles Maintenez châssis NOIR câble extrémité chargée. complètement batterie NÉGA- borne à NOIR câble extrémité châssis). contre court-circuiter attention bien faisant batterie chaque (A-B) borne à...
Page 43
FIG. manuel). section présente TON- INSTALLER POUR « (voir tondeuse dispositifs guides ainsi poulies, dans place bien courroie (B). d’embrayage fixe tension poulie dans courroie (C). centrale tension poulie retenue. dispositif courroie Assurez-vous (D). d’entrée transmission ventilateur sous soigneu- Enroulez tracteur.
Page 44
réglage. l’écrou contre fermement serrez clé avec place réglage inférieure 1/2’’ à 1/8’’ lame avant jusqu’à nécessaire ajustez mesures, 1/8’’. d’environ tondeuse modifie réglage l’écrou complet tour FIG. d’abord. contre-écrou 02950 tondeuse. baisser pour d’ajustement tondeuse. l’écrou Desserrez d’ajustement FIG. 02548 tondeuse.
Page 45
Fonctionnement section dans montré d’utiliser avant réglage roues ajustez haute. plus position à levage tondeuse. poulies place bien courroie Assurez-vous guides moteur poulie retenue(K). avec fixez-le guide collier dans d’embrayage câble carter (R). tondeuse braya trou tondeuse d’embrayage FIG. (J). ressort-arrêtoir d’une l’aide...
Page 46
tracteur. côté ressort-arrêtoir. solidement fixez tracteur châssis bras l’orifice Placez – CHÂSSIS LATÉRAUX SUSPENSION soit qu’elle jusqu’à tracteur, sous tracteur. glisser avant l’avant vers pointent laté- suspension bras Assurez-vous basse. plus position enclen- lentement abaissez-le levier fermement Tenez ressort. mé- possède levier ATTENTION...
Page 47
votre tracteur votre débris gazon, enlever pour feuilles à souffleuse l’air Utiliser tracteur. votre transmission, moteur l’intérieur. à l’eau l’infiltration soient transmission moteur votre nettoyer pour pression sous lavage d’arrosage tuyau d’un l’utilisation d’auto. cire avec peintes surfaces etc. l”huile l’essence, enlevant roues...
Page 48
vidange. soupape bouchon remettez vidange comme verrouillée position soit cheville montre d’une aiguilles sens dans rieur té l’in vers poussant vidange soupape serrez complètement, écoulée soit vidange. soupape aiguilles contraire sens dans tournant vers poussant vidange soupape FIG. VIDANGE TUBE D'HUILE VIDANGE SOUPAPE...
Page 49
pas. sont sont qu’elles l’apparence avoir peuvent lame. équilibrer pour clou avec fournies instructions suivez conique, utilisez vous conique équilibreuse dia. acier cheville d'une d’un besoin aurez vous lame, l’équilibre l’enlever sans N’essayez meule. lime avec affilée abîmera éventuellement excessive équilibrée lame équilibrée.
Page 50
GRAPHITE. TYPE POUDRE MODÉRATION AVEC SEULEMENT ÊTRE DOIVENT QU’ILS PENSEZ VOUS LUBRIFICATION À PALIERS DURABILITÉ SALETÉS POUSSIÈRE ATTIRENT NYLON. PALIERS GRAISSE HUILE METTEZ MOTEUR SOUS ENTRETIEN SECTION USAGE 10W30 VITESSE MENT CHAN PIVOTS TEUR ANTÉRIEURE ROUE PALIER PRESSION À GRAISSEUR BROCHE PRESSION À...
Page 51
utilisé. l'ac à terrain toujours choisissez accessoires, coupe. meilleure rendement basse suffisamment vitesse ment char dé rendement meilleur plein à commande avec avant l'herbe sécher Laissez tondeuse. L'herbe mouillée. elle quand l'herbe désirée. hauteur à faire doit haute. assez coupe pour l'appareil sèche.
Page 52
encore. essayez étrangleur dé essais, dé moteur encore. essayez rapi position à commande essais, quelques après démarre secondes quinze plus pendant démarreur N’utilisez démarre. moteur relâchez (START) démarrage d’une aiguilles sens dans clé sui- instructions lisez commencer, position à commande débrayée position à...
Page 53
FIG. lieu. ramasse-herbe sans déflecteur tondeuse N’utilisez ATTENTION: (DISENGAGED). position à d’accessoire d’embrayage TONDEUSE LAMES (ENGA- embrayée position à d’accessoire commande déplaçant tondeuse levier l’aide à désirée tonte hauteur collines. accidenté terrain quand s'arrête hésite moteur milieu assis bien rester devez Vous braya...
Page 54
hauteur à fois deuxième longue; fois première fois. deux tondre devez 15,24 plus mesure l’herbe rendement, tats. ré meilleurs pour souvent saison pendant po.) 7,62 plus pendant po.) (2-1/2 6,35 à tondue tondus. l’herbe hauteur terrain, à changer raient pour elles approximatives pas.
Page 55
moteur. commencer pour Utilisé D'ETRANGLE/BUSE inverse. sens qu'en pendant autre gazon à tondeuse pont POSI- » « (ROS) D'OPERATION frein pédale saisissent Serrures phares Allume LEGER commencer pour Utilisé D'ALLUMAGE Institute. dards Stan CHANGEMENT LEVIER ADAPTER D'ALLUMAGE COMMUTATEUR POSITION "ON" commandes différentes l'emplacement...
Page 56
propriété. l'endommagement blessures mort, conséquence pourrait évité, n'est s'il propriété. et/ou sérieuses conséquence comme avoir s'il qui, risque indique et/ou tracteur résulter pourrait situation symbole sans utilisé mineures blessures évité, n'est s'il qui, risque sérieuses. conséquence comme n'est s'il qui, risque mort conséquence...
Page 57
manuel). Entretien chapitres (Cf. correctement fonctionnent arrière marche fonctionnement l’opérateur présence Système sans fonctionne frein système toutes l’emplacement fonction vous assurez-vous moteur, plomb sans d’essence (rempli moteur. ATTENTION UTILISER À APPRENEZ VOUS ment soient fils attachées nexions toutes Assurez-vous guides-courroie. rieur té...
Page 58
suivantes instructions “Stop”. neutre. vitesse levier frein actionner tracteur, arrêter pour palette. hors diriger embrayage/frein pédale première. vitesse cée. maintenir d'embrayage/frein mort. point commande dé moteur, manuel). Fonctionnement section "POUR (voir moteur démarrez plus position dans d’accessoire dispositif placer levage levier (N).
Page 59
Fig. HARNAIS BANDE siège. interrupteur l'emballage. Débarrassez-vous siège l'assemblage pour côté mettez-les à siège fixent plate rondelle réglage. boulon serrer Figs. (Voir SIÈGE FIG. 03125 TION RALLONGE PATTES FENTES TEUR ADAP DIRECTION VOLANT PLATE GRANDE 5/16 FREIN RONDELLE 5/16 HEXAGONAL ÉCROU pour outils...
Page 61
SÉPARE 26-27 DÉPANNAGE 19-24 RÉGLAGES 15-18 manuel). PIÈCES tion (Voir proche plus centre disponible silencieux l’opérateur. etat maintenu être doit Quand applicables. locales lois pare-étincelles d’un muni n’est d’herbe d’arbrisseaux, d’arbres, près utilisé être doit à moteur d’un équipé tracteur propriétaire.
Page 62
descente. dans lentement tournez dans nécessaire, n’est cela pentes dans virage lentement. reculez arrière lames, dégagez montée, s’arrête pente. vers lames dégagez plus, n’adhèrent dans virages arrêts démarrages, pentes. dans vitesse devoir afin faible vitesse pénètre enfant moteur éteignez transversalement. maxi), (15°...
Page 63
s’éboule. bord par-dessus l’improviste à culbuter risque fossés ravins, proximité pied mettant machine stabiliser l’utilisez machine. risquent accessoires d’autres avec machine utilisez vous lorsque machine. culbuter faire vitesse brusquement jamais changez lents mouvements n’effectuez pente. vers lames dégagez plus, n’adhèrent dans virages arrêts...
Page 64
É.-U. IMPRIMÉ sécurité. tions ments aver lisez résulter peuvent sérieuses bles- sécurité. ments aver soigneusement AVERTISSEMENT: JETEZ www.poulan-pro.com l’utilisation. lors PELOUSE PB195H42LT struc vous sures tions struc tous suivez Lisez PROPRIÉTAIRE 02478 12.19.06 web: site notre sécurité lunettes toujours TRACTEUR MODÈLE:...