Page 1
IMPORTANT MANUAL OPERATOR'S MANUAL MODEL: PB195H42LT LAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 430094 Rev. 1 08.19.09 AP Do Not Throw Away 03076 WARNING: Read this Man u al and follow all Warnings and Safety Instructions. Fail ure to do so can re sult in serious in ju ry.
Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. WARNING: In order to prevent ac ci - den tal starting when setting up, trans- port ing, ad just ing or making repairs, al ways dis con nect spark plug wire...
Page 3
Safe Operation Practices for Ride-On Mowers III. CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the ma chine and the mowing activity. Never assume that children will remain where you last saw them. •...
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to ensure proper tightness. TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier.
• Connect switch to seat. • Place seat on seat pan so all three (3) bottom pads are positioned over large slotted holes in pan. • Push down on seat to engage pads in slots and pull seat towards rear of tractor. •...
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. REVERSE NEUTRAL ENGINE ON REVERSE ENGINE OFF OPERATION SYSTEM (ROS) OIL PRESSURE FUEL OVER TEMP LIGHT ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED LIGHTS ON FREE WHEEL (Automatic Models only)
Page 9
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. LIGHT SWITCH LIGHT SWITCH THROTTLE/CHOKE THROTTLE/CHOKE...
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safety glass es or eye shields while operating your tractor or per form ing any adjustments or repairs. We rec om mend a wide vision safety mask over spec- tacles or stan dard safety glasses.
Page 11
TO ADJUST MOWER CUT TING HEIGHT (See Fig. 10) The po si tion of the at tach ment lift le ver (A) de ter mines the cut ting height. Fig. 10 • Put attachment lift lever in desired cutting height slot. The cutting height range is ap prox i mate ly 1"...
TO OPERATE ON HILLS CAUTION: Do not drive up or down hills with slopes greater than 15° and do not drive across any slope. • Choose the lowest speed before starting up or down hills. • Avoid stopping or changing speed on hills. •...
WARM WEATHER STARTING (50°F (10°C) and above) • When engine starts, move the throttle control to the fast position. • The attachments and ground drive can now be used. If the engine does not accept the load, restart the engine and allow it to warm up for one minute using the choke as described above.
TRACTOR Always observe safety rules when per form ing any main- te nance. BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in high est gear on a level, dry concrete or paved surface, then brake must be checked and ad just ed. (See “TO CHECK BRAKE”...
V-BELTS Check V-belts for deterioration and wear after 100 hours of operation and replace if necessary. The belts are not ad just able. Re place belts if they begin to slip from wear. TRANSAXLE MAINTENANCE The transmission fan and cooling fins should be kept clean to assure proper cooling.
Page 17
ENGINE COOLING SYSTEM (See Fig. 20) Debris may clog the engine's air cooling system. Remove blower housing and clean the area shown to prevent over- heating and engine damage. AIR SCREEN CLEAN OUT CHAFF AND DEBRIS Fig. 20 MUFFLER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or damage.
SERVICE AND ADJUSTMENTS WARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: • Depress brake pedal fully and set parking brake. • Place motion control lever in neutral position. • Place attachment clutch in “DISENGAGED” position. •...
SERVICE AND ADJUSTMENTS • ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS - Position hole in arm over pin (B) on outside of tractor chassis and secure with retainer spring. • Repeat on opposite side of tractor. Fig. 24 • ATTACH REAR LIFT LINKS (C) - Lift rear corner of mower and position slot in link assembly over pin (D) on rear mower bracket and secure with washer and...
Page 20
SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn and lead you to think the mower is not adjusted properly.
SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 33) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL - • Remove mower from tractor (See “TO REMOVE MOW ER”...
Page 22
SERVICE AND ADJUSTMENTS TRANSAXLE MOTION CONTROL LEVER NEUTRAL ADJUSTMENT (See Fig. 35) The motion control lever has been pre set at the factory and adjustment should not be necessary. • Loosen adjustment bolt in front of the right rear wheel, and lightly tighten.
Page 23
SERVICE AND ADJUSTMENTS REPLACING BATTERY ( See Fig. 38 WARNING: Do not short battery ter mi- nals by allowing a wrench or any other object to contact both terminals at the same time. Before connecting battery, remove metal bracelets, wristwatch bands, rings, etc.
Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open flame or spark.
PROBLEM CAUSE 1. Out of fuel. Will not start 2. Engine not “CHOKED” properly. 3. Engine flooded. 4. Bad spark plug. 5. Dirty air filter. 6. Dirty fuel filter. 7. Water in fuel. 8. Loose or damaged wiring. 9. Carburetor out of adjustment. 10.
Page 26
TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues 1. Faulty operator-safety presence control system. to run when oper- ator leaves seat with attachment clutch engaged 1. Worn, bent or loose blade. Poor cut - uneven 2. Mower deck not level. 3. Buildup of grass, leaves, trash under mower. 4.
The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi- als and work man ship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, without charge for parts or labor incurred in replacing parts, any part which we find to be defective due to materials or workmanship.
Page 29
1975. droits donne vous garantie Cette vous. conséquent, implicite garantie d’une Certaines FABRICANT. EXPLICITES IMPLICITE GARANTIE TOUTE CONSÉQUENT Ontario concession- l’adresse ainsi machine contactez: concessionnaire à machine votre retourner standard, visserie normaux, réglages normal. usage livraison modifiés, été produits ins- conformément entretenus quatre-vingt-...
Page 31
'ON'. position dans couper avant lent) rapide (entre position dans commande manuel.) Reglages Revision section ENLEVER "POUR (Voyez d'axe. carrée transmission. déplacement. d'entraînement courroie manuel. Entretien section dans “NETTOYAGE” positionengagée. libre roue commande l’alternateur. régulateur. connexions. toutes Vérifiez/remplacez batterie. fusible. connexions.
Page 33
SONT D’ÉCHAPPEMENT ENDROITS QUAND TRACTEUR JAMAIS COUVREZ tracteur. condensation formation permet obstrue plastique plastique. N’uti perméable. couverture avec saleté. poussière couvrez-le possible, l’intérieur, à tracteur causera l’essence dans saleté et/ou rouiller. à commence s’il d’essence l’autre. à saison d’une d’essence SUPPLÉMENTAIRE d’allumage.
Page 34
réglage. et/ou réaration autorisé d'entretien centre gazon à tondeuse teur, avec problèms cause tion fonc moteur votre réglable. CARBURATEUR voir né réglage nécessaire. réglage l’usine à préréglée été COMMANDE voir nécessaire, réglage nécessaire. réglage l’usine à préréglée été CÂBLE manuel. Utilisation section “PURGEZ...
Page 35
Fig. CHARGÉE MENT TIÈ BATTERIE batteries. deux ROUGE câble complètement. chargée batterie châssis NOIR câble premièrement RENVERSEZ CÂBLES, d’es réservoir loin câbles Maintenez châssis NOIR câble extrémité chargée. complètement batterie NÉGA- borne à NOIR câble extrémité châssis). contre court-circuiter attention bien faisant batterie...
Page 36
Fig. 02952 manuel). section présente TON- INSTALLER POUR « (voir tondeuse dispositifs guides ainsi poulies, dans place bien courroie (B). d’embrayage fixe tension poulie dans courroie (C). centrale tension poulie retenue. dispositif courroie Assurez-vous (D). d’entrée transmission ventilateur sous soigneu- Enroulez tracteur.
Page 37
réglage. l’écrou contre fermement serrez clé avec place réglage inférieure 1/2" à 1/8" lame avant jusqu’à nécessaire ajustez mesures, 1/8". d’environ tondeuse modifie réglage l’écrou complet tour Fig. d’abord. contre-écrou 02950 tondeuse. baisser pour d’ajustement tondeuse. l’écrou Desserrez d’ajustement tondeuse. l’avant abaisser pour...
Page 38
"UTILISATION" section dans montré d’utiliser avant réglage roues ajustez haute. plus position à levage tondeuse. poulies place bien courroie Assurez-vous Fig. moteur poulie retenue(K). avec fixez-le guide collier dans d’embrayage câble carter (R). tondeuse braya trou tondeuse d’embrayage Fig. (J). ressort-arrêtoir d’une l’aide...
Page 39
celui-ci. soit qu’elle jusqu’à tracteur, sous tracteur. glisser avant l’avant vers pointent laté- suspension bras Assurez-vous basse. plus position enclenchez- lentement abaissez-le levier fermement Tenez ressort. mécan- possède levier ATTENTION basse. plus position à levage stationnement. frein surface trouve tracteur 23–28) Figs.
Page 40
tondeuse. votre tracteur ainsi feuilles gazon, enlever compressé l’air Utiliser tracteur. abrégera ceci transmission, s’infiltre l’eau l’intérieur. à l’eau recouverts soient transmission moteur trac- votre nettoyer pour pression sous d’arrosage tuyau d’un l’utilisation d’auto. cire avec peintes surfaces etc. l”huile l’essence, enlevant roues...
Page 41
séchés. gomme fibres paille, enlever pour comprimé l’air Net- surchauffage. cause à moteur pour céréale balle saleté libre D’AIR TAMIS moteur. manuel Voir sales. endroits dans utilisé souvent plus à filtre avec correctement fonctionne moteur. manuel Voir année. plus utilisé été...
Page 42
manuel). REGLAGES ENTRETIEN dans BATTERIE” “REPLACER (Voir pétrolatum. graisse avec brillent. qu’ils jusqu’à métallique avec batterie câbles bouts séchez-la. fraîche, l’eau avec batterie enlevez ROUGE batterie NOIR batterie câble débranchez puissance. bornes batterie saleté BORNES: BATTERIE d'électrolyte. vérifie nécessaire n'est couvercles.
Page 43
GRAPHITE. TYPE POUDRE SEC, LUBRIFIANT AVEC SEULEMENT UTILISEZ LUBRIFIÉS, PENSEZ VOUS AUTOMATIQUE. LUBRIFICATION DURABILITÉ DIMINUENT SALETÉS LUBRIFIANTS NYLON. PALIERS POINTS GRAISSE HUILE moteur sous ENTRETIEN section usage 01965 ➁ MOTEUR ANTÉRIEURE ROUE PALIER PRESSION À ➀ GRAISSEUR BROCHE PRESSION ➀ À...
Page 44
utilisé. l'ac à terrain toujours choisissez accessoires, coupe. meilleure donne basse suffisamment vitesse correct. ment char dé rendement pour plein à commande avec tondre. avant l'herbe sécher Laissez tondeuse. mouillée L'herbe mouillée. elle quand désirée. hauteur à faire doit haute. assez coupe pour...
Page 45
sui- instructions lisez commencer, position à commande débrayée position à d’accessoire l’embrayage position à déplacement commande stationnement. frein braya d'em pédale enfoncez siège, engagée. position dans soit libre roue commande l’es déplacer pour temps plus faudra moteur fois première pour moteur MOTEUR DÉMARRER...
Page 46
Fig. lieu. ramasse-herbe sans déflecteur tondeuse N’utilisez ATTENTION: (DISENGAGED). posi- à d’accessoire d’embrayage commande TONDEUSE LAMES (ENGAGED). embrayée position à d’accessoire commande déplaçant tondeuse levier l’aide à désirée tonte hauteur collines. accidenté terrain quand s'arrête hésite moteur milieu assis bien rester devez Vous...
Page 47
RACCOURCIRA. TRANSMISSION DURABILITÉ PAS, FAITES CHANGER AVANT TRACTEUR ARRÊTIEZ VOUS ASSUREZ-VOUS déplacement. pour frein/embrayage pédale position à vitesse changement Fig. position à vitesse changement frein/embrayage pédale avec tracteur vitesse. commandées sont déplacement RECULER POUR Fig. performance meilleure permet (rapide) moteur. l’efficacité...
Page 48
moteur quand tracteur remorquage transmission débraye LIBRE ROUE moteur vitesse commander démarrer permet GAZ/ÉTRANGLEUR actionné attachement autre tout fonctionnement Permet "ON" ’OPÉRA- PRÉSENCE SYSTÈME (BRAKE). pédale bloque STATIONNEMENT d’allumer/éteindre permet LUMIÈRES Institute. dards Stan DÉPLACEMENT DÉPLACEMENT DE COMMANDE COMMANDE DE LEVIER LEVIER D’ALLUMAGE D’ALLUMAGE...
Page 49
propriété. l'endommagement blessures mort, conséquence pourrait évité, n'est s'il propriété. et/ou sérieuses conséquence comme avoir s'il qui, risque indique et/ou tracteur résulter pourrait situation symbole sans utilisé mineures blessures évité, n'est s'il qui, risque sérieuses. conséquence comme n'est s'il qui, risque mort conséquence...
Page 50
nuel dans TRANSMISSION” DÉMARRER “POUR sections sion trans purge démarrage instructions Suivez fois. première démarrer avant transmission purger Entretien Fonctionnement chapitres fonctionnent (ROS) arrière marche Système l’opérateur présence que. sans fonctionne frein système des. toutes l’emplacement pre- vous assurez-vous moteur, plomb sans d’essence...
Page 51
Fig. HARNAIS BANDE réglage. boulon serrer Figs. (Voir SIÈGE ROULER. FAISANT TRACTEUR RETIREZ VOUS CREVER POURRAIENT ELLES LES. AGRAFES ATTENTION calandre. capot direction. centre dans direction volant garniture fond. à serraz 5/16 frein, rondelle 5/16 plate, rondelle direction. volant l’adaptateur l'inte- à...
Page 52
Clé(s) Vidange Tube Guide-pente Boulon Siège Rondelle Siège Adaptateur direction Manchon rallonge Boulon Arbre direction Volant direction Rondelle volant Insert Rondelle Serrure direction Volant MONTAR PIEZAS...
Page 53
25-26 DÉPANNAGE 18-23 RÉGLAGES 14-16 manuel). PIÈCES tion (Voir proche plus centre disponible silencieux l’opérateur. etat maintenu être doit Quand applicables. locales lois pare-étincelles d’un muni n’est d’herbe d’arbrisseaux, d’arbres, près utilisé être doit à moteur d’un équipé tracteur propriétaire. manuel Entretien sections...
Page 54
descente. dans lentement tournez dans nécessaire, n’est cela pentes dans virage lentement. reculez arrière lames, dégagez montée, s’arrête pente. vers lames dégagez plus, n’adhèrent dans virages arrêts démarrages, pentes. dans vitesse devoir afin faible vitesse pénètre enfant moteur éteignez transversalement. maxi), (15°...
Page 55
s’éboule. bord par-dessus l’improviste à culbuter risque fossés ravins, proximité pied mettant machine stabiliser raides. très pentes l’utilisez machine. à nuire risquent accessoires d’autres avec machine utilisez vous lorsque machine. culbuter faire vitesse brusquement jamais changez lents mouvements n’effectuez pente. vers lames dégagez...
Page 56
AVERTISSEMENT: JETEZ www.poulan-pro.com l’utilisation. lors PELOUSE tions struc lisez vous sures bles ments aver Lisez PROPRIÉTAIRE 03076 Rev. 08.14.09 web: site notre sécurité lunettes toujours TRACTEUR PB195H42LT MODÈLE: MANUEL IMPORTANT 430094 Visitez Portez MANUEL...