Napoleon GVFS60-P Installation And Operation Instructions Manual
Unvented millivolt system natural and propane gas fireplace
Hide thumbs
Also See for GVFS60-P:
- Installation and operating instructions manual (24 pages) ,
- Installation and operating instructions manual (20 pages) ,
- Installation and operating instructions manual (24 pages)
Table of Contents
Advertisement
INSTALLER: THESE INSTRUCTIONS MUST BE CONVEYED TO AND REMAIN WITH THE HOMEOWNER
CERTIFIED UNDER AMERICAN NATIONAL STANDARDS, ANSI Z21.11.2b, VOLUME II FOR UNVENTED ROOM HEATERS.
WARNING: If the information in these instructions is not followed exactly, a fire or
explosion may result causing property damage, personal injury or death.
Do not store or use gasoline or other flammable vapours and liquids in the vicinity of
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your building.
Installation and service must be performed by a qualified installer, service agency or the
gas supplier.
This is an unvented gas-fired heater that uses air (oxygen) from the room in which it is
installed. Provisions for adequate combustion and ventilation air must be provided.
Fax: (705)722-6031 Email: ask@napoleon.on.ca
Web: www.napoleon.on.ca
UNVENTED MILLIVOLT SYSTEM
INSTALLATION AND OPERATION INSTRUCTIONS FOR
UNVENTED GAS FIREPLACE
NATURAL GAS MODEL
PROPANE GAS MODEL
CERTIFIED FOR THE UNITED STATES USING ANSI / AGA METHODS
FOR YOUR SAFETY
this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
Wolf Steel Ltd., RR#1, 9 Napoleon Rd.,
Barrie, ON., Canada L4M 4Y8 (705)721-1212
GVFS60-N
GVFS60-P
• Immediately call your gas supplier from a
neighbour's phone. Follow the gas
supplier's instructions.
• If you cannot reach your gas supplier, call
the fire department.
1
W415-0204 / C / 10.02.01
Advertisement
Table of Contents
Related Manuals for Napoleon GVFS60-P
Summary of Contents for Napoleon GVFS60-P
-
Page 1: For Your Safety
Barrie, ON., Canada L4M 4Y8 (705)721-1212 Fax: (705)722-6031 Email: ask@napoleon.on.ca Web: www.napoleon.on.ca UNVENTED GAS FIREPLACE GVFS60-N NATURAL GAS MODEL GVFS60-P PROPANE GAS MODEL FOR YOUR SAFETY this or any other appliance. • Immediately call your gas supplier from a neighbour's phone. Follow the gas supplier's instructions. -
Page 2: Table Of Contents
TABLE OF CONTENTS PG 3-4 INTRODUCTION Warranty General Instructions Shipping Bracket Mobile home installation General Information LOCATIONS & CLEARANCES INSTALLATION Combustion and Ventilation Air Provisions Installation Examples Gas Installation FINISHING Front Casting Installation Log Placement PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE •... -
Page 3: Warranty
NAPOLEON gas fireplaces are manufactured under the strict Standard of the world recognized NAPOLEON products are designed with superior components and materials, assembled by trained craftsmen who take great pride in their work. The burner and valve assembly are leak and test-fired at a quality test station. The complete fireplace is test-fired and thoroughly inspected by a qualified technician before packaging to ensure that you, the customer, receives the quality product that you expect from NAPOLEON NAPOLEON GAS FIREPLACE PRESIDENT'S LIFETIME LIMITED WARRANTY... -
Page 4: General Instructions
GENERAL INSTRUCTIONS THIS GAS FIREPLACE SHOULD BE INSTALLED AND SERVICED BY A QUALIFIED INSTALLER to conform with local codes. In absence of local codes, install the GVFS60 to the current National Fuel Gas Code, ANSI Z223.1 In- stallation Code which can be obtained from: American Nation Standards Institute Inc. -
Page 5: Installation
LOCATION AND CLEARANCES Provide adequate ventilation and combustion air. Provide adequate accessibility clearance for servic- ing and operating the stove. Never obstruct the front opening of the stove. As long as clearance to combustibles is kept within the required distances, the most desirable and beneficial lo- cation for a Napoleon stove is in the centre of a building, thereby allowing the most efficient use of the heat created. - Page 6 Room Volume = Length x Width x Height Max BTU/hr = Room Volume x 1000 ÷ 50 ROOM 1 H E I G H T H E I G H T H E I G H T H E I G H T H E I G H T L E N G T H L E N G T H...
-
Page 7: Gas Installation
GAS INSTALLATION 1. Move the stove into position. We recommend secur- ing the stove to the floor, in all cases. Levelling / securing kit GDSLL-KT may be used for this purpose. 2. Install rigid black pipe, 1/2" type-L copper tubing or, if local codes permit, a 3/8"... -
Page 8: Log Placement Instructions
LOG PLACEMENT INSTRUCTIONS Blocked burner ports can cause an incorrect flame pat- tern, carbon deposits and delayed ignition. PHAZER glow when exposed to direct flame and provide a unique and realistic glowing effect. Use only certified PHAZER logs available from your Napoleon / Wolf Steel Ltd. dealer. Place log #1 onto the burner, centering it onto the burner tray and pushing it as close to the rear wall of the firebox as possible. -
Page 9: Blower Installation
BLOWER INSTALLATION ON/OFF SWITCH BRACKET COVER PLATE ACCESS PLATE 1. Ensure that the access cover plate has been installed. 2. Remove the on/off switch bracket and the cover plate below it. The cover plate may now be discarded. 3. Decide which side of the blower housing you prefer the on/off switch to be located on. -
Page 10: Operation / Maintenance
OPERATION / MAINTENANCE OPERATING INSTRUCTIONS If heater shuts off, do not relight until you provide fresh air. If heater keeps shutting off, have it serv- iced. Keep burner and control compartment clean. FOR YOUR SAFETY READ BEFORE OPERATING W W W W W ARNING: ARNING: ARNING: ARNING:... -
Page 11: Maintenance
MAINTENANCE TURN OFF THE GAS AND ELECTRICAL POWER BEFORE SERVICING THE FIREPLACE. CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servic- ing. This heater should be inspected and serviced before use and at least annually by a qualified service person. -
Page 12: Replacements
REPLACEMENTS ORDERING REPLACEMENT PARTS Contact your dealer or the factory for questions concern- ing prices and policies on replacement parts. Normally all parts can be ordered through your Napoleon dealer or distributor. When ordering replacement parts always give the following information: 1. -
Page 13: Trouble Shooting Guide
TROUBLE SHOOTING GUIDE SYMPTOM PROBLEM Main burner goes Pilot flame is not large out; pilot stays on. enough or not engulfing the thermopile Thermopile shorting Remote wall switch wire is too long; too much resis- tance in the system. Faulty thermostat or switch. Main burner goes Insufficient air supply out;... - Page 14 SYMPTOM Pilot goes Gas piping is undersized. while standing; Main burner is in 'OFF' position. Flames are con- Unit is over-fired or under- sistently too large fired. small. Carboning occurs. Carbon is being Air shutter has become deposited on logs blocked combustion Flame is impinging on the...
- Page 15 Wolf Steel Fireplace Service History This fireplace must be serviced annually depending on usage. Service Technician Date Dealer Name Service Performed Special Concerns Name...
- Page 16 NOTES: W415-0204 / C / 10.02.01...