Summary of Contents for Chamberlain HandyLift Deluxe CR650EVO
Page 1
chamberlaindiy.com.au chamberlaindiy.co.nz CR650EVO Garage Roller Door Opener Installation and Operating Instructions Owners Copy: Please keep these instructions for future reference This manual contains IMPORTANT SAFETY information DO NOT PROCEED WITH THE INSTALLATION BEFORE READING THOROUGHLY...
START BY READING THESE IMPORTANT SAFETY INSTRUCTIONS WARNING • Failure to comply with the following instructions may result in serious personal injury or property damage. • Read and follow all instructions carefully. • The garage door opener is designed and tested to offer safe service provided it is installed and operated in strict accordance with the instructions in this manual.
TOOLS REQUIRED CARTON INVENTORY 1. Instruction manual (this document) 1. Ladder 2. Stop collar 2. Adjustable wrench for U-bolts already installed 3. Clamp bracket on the door 4. Release handle, cord and risk of entrapment card 3. 8 mm socket, 10 mm socket and 13 mm extended 5.
TESTING THE DOOR Complete the following test to ensure your door is well balanced, and not sticking or binding: • Disable all locks and remove any ropes connected to the garage door. • Lift the door to about halfway and then release it. The door should remain spring balanced.
THE RELEASE HANDLE & CORD • Thread one end of the rope through the hole in the top of the red release handle so that “NOTICE” reads right side up as shown. • Secure with an overhand knot at least 25 mm from the end of the rope to prevent slipping.
Page 7
Optional accessory not provided NOTE: Almost all garage doors do not require extension poles. If you require extension poles please call Chamberlain Customer Service on Reinforcing Brace AUS - 1800 665 438 or NZ - 0800 653 667 and we will provide the extension pole kit.
INSTALLATION PROCEDURE Do not allow people to walk under or around the door during the installation process as serious injury can occur. NOTE: The opener can be installed on either side of the door. The following instructions are for Rope RIGHT HAND INSTALLATIONS (as illustrated i.e.
SETTING THE LIMITS FOR RIGHT OR LEFT HAND OPERATION AND FORCE Travel limits set how far your door goes up and down. Your opener must be configured correctly for right or left hand installation to operate correctly, if not the door will rotate in the reverse direction. NOTE: The HandyLift Plus CR650EVO opener is factory configured for right hand installation.
Page 10
TESTING THE SAFETY REVERSE SYSTEM The safety reverse system test is important. The garage door must reverse on contact with a 40 mm obstacle laid flat on the floor. Failure to properly adjust the opener may result in serious personal injury from a closing garage door.
The Protector System is now activated. Checks IRs operate correctly. SAFETY FIRST! Whilst Chamberlain have engineered safety features into your garage door opener, we urge you to consider fitting IR Beams to your new garage door opener. In many countries these devices are compulsory to assist in preventing serious injury or property damage.
WIRELESS PROGRAMING (OPTIONAL ACCESSORIES) NOTE: Transmitter(s) supplied with your opener are factory programmed. Activate the opener only when the door is in full view, free of obstruction and properly adjusted. No one should enter or leave garage whilst the door is in motion. Do not allow children to operate push button(s) or transmitter(s).
• when IR Beams are triggered with the door in the Operating Frequency: 433.30/433.92/434.54 MHz Open position. (the light turns off automatically after 2-1/2 minutes.) SPECIAL NOTE: Chamberlain strongly recommends that the Protector System be installed on all garage door openers.
REPLACE BATTERIES IN REMOTES Battery of the remote control: The batteries in the remote have an extremely long life. If the transmission range decreases, the batteries must be replaced. Batteries are not covered by the warranty. To prevent SERIOUS INJURY OR DEATH: observe the following instructions for the battery - NEVER allow small children near batteries.
ACCESSORIES 1. Model E940C 1 Channel transmitter 4. Model 1702AML Outside quick release 2. Model E950C 2 Channel mini transmitter 5. Model 774AML The Protector System (IR Beams) 3. Model E840C Wireless Keypad TYPICAL WIRING DIAGRAM - Information for Service Personnel white/black white Keyswitch or...
TROUBLESHOOTING 8. The door opens but will not close or reverses 1. The opener will not operate from either the while closing: ACTIVATION button or the transmitters : • Is something obstructing the door? Pull the manual • Does the opener have electric power? Plug a lamp into release handle.
Unit to you. purchaser, with this Chamberlain Limited Warranty. This Chamberlain Limited Warranty does not cover any failure of, or defect in, the Unit due to: The benefits given to you under this Chamberlain Limited Warranty are...