Toro Greensmaster 3150 Service Manual

Toro Greensmaster 3150 Service Manual

Hide thumbs Also See for Greensmaster 3150:
Table of Contents

Advertisement

Preface
The purpose of this publication is to provide the service
technician with information for troubleshooting, testing
and repair of major systems and components on the
Greensmaster 3150 (Model 04358).
REFER TO THE TRACTION UNIT AND CUTTING
UNIT OPERATOR'S MANUALS FOR OPERATING,
MAINTENANCE AND ADJUSTMENT INSTRUC-
TIONS. For reference, insert a copy of the Operator's
Manuals and Parts Catalogs for your machine into
Chapter 2 of this service manual. Additional copies of
the Operator's Manuals and Parts Catalog are available
on the internet at www.Toro.com.
The Toro Company reserves the right to change product
specifications or this publication without notice.
Greensmaster
This safety symbol means DANGER, WARNING
or CAUTION, PERSONAL SAFETY INSTRUC-
TION. When you see this symbol, carefully read
the instructions that follow. Failure to obey the
instructions may result in personal injury.
NOTE: A NOTE will give general information about the
correct operation, maintenance, service, testing or re-
pair of the machine.
IMPORTANT: The IMPORTANT notice will give im-
portant instructions which must be followed to pre-
vent damage to systems or components on the
machine.
E The Toro Company - - 2012
Part No. 12191SL

Service Manual

(Model 04358)
R
3150

Advertisement

Table of Contents
loading

Summary of Contents for Toro Greensmaster 3150

  • Page 1: Service Manual

    The Toro Company reserves the right to change product IMPORTANT: The IMPORTANT notice will give im- specifications or this publication without notice. portant instructions which must be followed to pre- vent damage to systems or components on the machine.
  • Page 2 This page is intentionally blank. Greensmaster 3150...
  • Page 3: Table Of Contents

    ....9 -- 5 Wire Harness Drawings ....9 -- 12 Greensmaster 3150...
  • Page 4 This page is intentionally blank. Greensmaster 3150...
  • Page 5: Safety Instructions

    ..... SAFETY AND INSTRUCTION DECALS ..Greensmaster 3150 Page 1 - - 1 Safety...
  • Page 6: Safety Instructions

    Safety Instructions The Greensmaster 3150 was tested and certified by Toro for compliance with national and international stan- WARNING dards as specified in the Operator’s Manual. Although hazard control and accident prevention partially are de- pendent upon the design and configuration of the ma-...
  • Page 7: While Operating

    Shut the engine off before emp- tying the baskets. Greensmaster 3150 Page 1 - - 3 Safety...
  • Page 8: Maintenance And Service

    Use paper or cardboard, not hands, to search for leaks. timum performance and continued safety certification of Hydraulic fluid escaping under pressure can have suffi- the machine, use genuine Toro replacement parts and accessories. Replacement parts and accessories made cient force to penetrate skin and do serious damage. If...
  • Page 9: Safety And Instruction Decals

    3150. If any decal becomes illegible or damaged, in- stall a new decal. Part numbers are listed in your Parts Catalog and Operator’s Manual. Order replacement de- cals from your Authorized Toro Distributor. Greensmaster 3150 Page 1 - - 5...
  • Page 10 This page is intentionally blank. Safety Page 1 - - 6 Greensmaster 3150...
  • Page 11: Product Records

    ......Product Records Insert a copy of the Operator’s Manual and Parts Cata- log for your Greensmaster 3150 at the end of this chap- ter. Additionally, if any optional equipment or accessories have been installed to your machine, insert the Installation Instructions, Operator’s Manuals and...
  • Page 12: Equivalents And Conversions

    Equivalents and Conversions 0.09375 Product Records and Maintenance Page 2 - - 2 Greensmaster 3150...
  • Page 13: Torque Specifications

    For critical applications, as determined reduced by 25% for lubricated fasteners to achieve by Toro, either the recommended torque or a torque that the similar stress as a dry fastener. Torque values may is unique to the application is clearly identified and spe- also have to be reduced when the fastener is threaded cified in this Service Manual.
  • Page 14: Standard Torque For Dry, Zinc Plated And Steel Fasteners (Inch Series)

    The specific torque value should be determined based on the fastener size, the aluminum or base material strength, length of thread engagement, etc. Product Records and Maintenance Page 2 - - 4 Greensmaster 3150...
  • Page 15: Standard Torque For Dry, Zinc Plated And Steel Fasteners (Metric Fasteners)

    The specific torque value should be determined based on the fastener size, the aluminum or base material strength, length of thread engagement, etc. Greensmaster 3150 Page 2 - - 5 Product Records and Maintenance...
  • Page 16 Conversion Factors in- -lb X 11.2985 = N- -cm N- -cm X 0.08851 = in- -lb ft- -lb X 1.3558 = N- -m N- -m X 0.7376 = ft- -lb Product Records and Maintenance Page 2 - - 6 Greensmaster 3150...
  • Page 17: General Information 3

    ......Fuel Evaporative Control System ... . . BRIGGS & STRATTON VANGUARD V--TWIN OHV RE- PAIR MANUAL Greensmaster 3150 Page 3 - - 1 Engine...
  • Page 18: General Information

    V-Twin OHV engines are supplied through your local lo- engine used in the Greensmaster 3150. cal Toro distributor. If no parts list is available, be sure to provide your distributor with the Toro model and serial Most repairs and adjustments require tools which are number along with the engine model and serial number.
  • Page 19: Specifications

    1.75 U.S. quarts (1.65 liters) with new filter Ignition System Flywheel magneto, twin electronic armatures Spark Plugs Champion RC 14YC (or equivalent) Spark Plug Gap 0.030” (0.76 mm) Alternator 16 Amp Dry Weight (approximate) 84 lb (38 kg) Greensmaster 3150 Page 3 - - 3 Engine...
  • Page 20: Service And Repairs

    6. Grommet (4 used) 14. Fuel hose (shut- -off valve to filter) 21. Fuel vent hose (fitting to cannister) 22. Grommet 7. Flat washer (4 used) 15. Fuel shut- -off valve 8. Hose support clamp Engine Page 3 - - 4 Greensmaster 3150...
  • Page 21 4. Remove four (4) cap screws (item 9), grommets (item 6) and flat washers (item 7) securing the fuel tank to the vehicle frame. Remove the fuel tank from the ve- hicle frame. Greensmaster 3150 Page 3 - - 5 Engine...
  • Page 22 54. Pump hub 17. Lock washer 36. Hose clamp 55. Piston pump assembly 18. Cap screw (4 used) 37. Hose (to air cleaner base) 19. Pump adapter 38. Hex nut 56. Key Engine Page 3 - - 6 Greensmaster 3150...
  • Page 23: Engine Removal

    2. Apply antiseize lubricant to bore of engine hub. (3) engine mount flange nuts (item 7), cap screws (item Place key (item 48) into slot on the engine crankshaft. 1), flat washers (item 2) and spacers (item 3). Greensmaster 3150 Page 3 - - 7 Engine...
  • Page 24 7. Apply Loctite #242 (or equivalent) to threads of en- gine hub set screws (item 47). Secure hub to crankshaft with two (2) set screws. Torque set screws from 90 to 110 in- -lb (10.2 to 12.4 N- -m). Engine Page 3 - - 8 Greensmaster 3150...
  • Page 25 This page is intentionally blank. Greensmaster 3150 Page 3 - - 9 Engine...
  • Page 26 Figure 5. The fuel tank on Greensmaster 3150 machines uses a NOTE: The purge hose assembly (item 5 in Fig. 6) and non--vented fuel cap. To connect the tank to the evapo- tee hose assembly (item 10 in Fig.
  • Page 27 A. If either purge hose assembly (item 5) or T--hose assembly (item 10) was removed, make sure that installation is correct. B. Make sure that fuel hoses are not kinked after installation. Also, secure all hoses with hose clamps. Greensmaster 3150 Page 3 - - 11 Engine...
  • Page 28 This page is intentionally blank. Engine Page 3 - - 12 Greensmaster 3150...
  • Page 29: Hydraulic Schematic 4

    ......Adjust Manifold Relief Valves (R2) ... . Greensmaster 3150 Page 4 - - 1 Hydraulic System...
  • Page 30: Specifications

    Cutting Unit Lower (R2) 400 PSI (28 bar) above Charge Pressure Hydraulic Filter Spin--on cartridge type Hydraulic Oil See Operator’s Manual Hydraulic Reservoir Reservoir (with leak detector) capacity 8.5 gal. U.S. (32.2 L) Hydraulic System Page 4 - - 2 Greensmaster 3150...
  • Page 31: General Information

    General Information Operator’s Manual The Operator’s Manual provides information regarding the operation, general maintenance and maintenance intervals for your Greensmaster 3150. Refer to that pub- lication for additional information when servicing the machine. Check Hydraulic System Fluid The hydraulic system on the Greensmaster 3150 is de- signed to operate on high quality hydraulic fluid.
  • Page 32: Towing Traction Unit

    Towing Traction Unit In case of emergency, the Greensmaster 3150 can be towed for a short distance. However, Toro does not rec- ommend this as a standard practice. IMPORTANT: Do not tow the machine faster than 2 to 3 mph because drive system may be damaged. If machine must be moved a considerable distance, transport it on a truck or trailer.
  • Page 33: Hydraulic Hose And Tube Installation

    85 to 105 ft--lb (116 to 142 N--m) 1 7/16 -- 12 110 to 136 ft--lb (150 to 184 N--m) 1 11/16 -- 12 140 to 172 ft--lb (190 to 233 N--m) Figure 5 Greensmaster 3150 Page 4 - - 5 Hydraulic System...
  • Page 34 202 to 248 ft--lb (274 to 336 N--m) 121 to 149 ft--lb (165 to 202 N--m) 1 5/8 -- 12 247 to 303 ft--lb (335 to 410 N--m) 149 to 183 ft--lb (202 to 248 N--m) Figure 7 Hydraulic System Page 4 - - 6 Greensmaster 3150...
  • Page 35 1.00 + 0.25 6 (3/8 in.) 1.50 + 0.25 8 (1/2 in.) 1.50 + 0.25 10 (5/8 in.) 1.50 + 0.25 12 (3/4 in.) 1.50 + 0.25 16 (1 in.) 1.50 + 0.25 Greensmaster 3150 Page 4 - - 7 Hydraulic System...
  • Page 36: Hydraulic Schematic

    Hydraulic Schematic Hydraulic System Page 4 - - 8 Greensmaster 3150...
  • Page 37 This page is intentionally blank. Greensmaster 3150 Page 4 - - 9 Hydraulic System...
  • Page 38: Hydraulic Flow Diagrams

    Hydraulic Flow Diagrams Hydraulic System Page 4 - - 10 Greensmaster 3150...
  • Page 39: Traction Forward And Reverse

    NOTE: The shuttle valve assembly is located in the pis- ton pump back plate. Access to the shuttle valve re- quires removal of the back plate from the piston pump. Greensmaster 3150 Page 4 - - 11 Hydraulic System...
  • Page 40 Hydraulic System Page 4 - - 12 Greensmaster 3150...
  • Page 41: Raise And Lower Cutting Units

    The lift cylinder position is locked in place since there is no complete circuit of flow to and from the lift cylinders. Greensmaster 3150 Page 4 - - 13 Hydraulic System...
  • Page 42 Hydraulic System Page 4 - - 14 Greensmaster 3150...
  • Page 43: Mow And Backlap

    (MB) and to the reel motors that are connected in series. Oil flows through the center reel motor, right front motor and then left front motor as it turns the reel motors in the backlap direction. Greensmaster 3150 Page 4 - - 15 Hydraulic System...
  • Page 44 Hydraulic System Page 4 - - 16 Greensmaster 3150...
  • Page 45: Right And Left Turn

    (T) and then to the traction charge circuit. The steering valve returns to the neutral position when 1160 PSI turning is complete. STEERING VALVE To Manifold Port ST To Manifold Port P2 From Gear Pump Figure 10 Greensmaster 3150 Page 4 - - 17 Hydraulic System...
  • Page 46: Special Tools

    Special Tools Order these special tools from your Toro Distributor. Hydraulic Pressure Test Kit Use to take various pressure readings for diagnostic tests. Quick disconnect fittings provided attach directly to mating fittings on machine test ports without tools. A high pressure hose is provided for remote readings.
  • Page 47 Toro Part Number: TOR6011 NOTE: This kit does not include hydraulic hoses (see Hydraulic Hose Kit TOR6007 above). NOTE: Replacement filter element is Toro part number TOR6012. Filter element cannister tightening torque is 25 ft- -lb (34 N- -m). Hydraulic Hose Kit...
  • Page 48: Measuring Container

    Hydraulic Test Fitting Kit This kit includes a variety of O--ring face seal fittings to TORO TEST FITTING KIT (NO. TOR4079) enable you to connect test gauges into the system. The kit includes: tee’s, unions, reducers, plugs, caps and male test fittings.
  • Page 49: Troubleshooting

    Wheel Motor Efficiency and Reel Motor Case Drain Flow Tests in the Testing section of this chapter). Piston (traction) pump is worn or damaged (see Piston (Traction) Pump Flow Test in the Testing section of this chapter). Greensmaster 3150 Page 4 - - 21 Hydraulic System...
  • Page 50: Traction Circuit Problems

    Due to engine output, it is unlikely that traction pressure will reach relief valve settings. If, however, a piston pump relief valve is leaking or otherwise faulty, traction performance would be affected. Hydraulic System Page 4 - - 22 Greensmaster 3150...
  • Page 51: Mow Circuit Problems

    A cutting unit problem exists (see Chapter 7 -- DPA Cutting Units). Hydraulic manifold reel circuit cartridge is leaking or damaged. Excessive internal wear in reel motor exists (see Reel Motor Case Drain Flow Test in the Testing section of this chapter). Greensmaster 3150 Page 4 - - 23 Hydraulic System...
  • Page 52: Lift/Lower Circuit Problems

    (Rear Section) Flow Test in the Testing section of this chapter). Cutting units raise, but will not stay Hydraulic manifold solenoid valve (S4) leaks or is damaged. Lift cylinders leak internally. Hydraulic System Page 4 - - 24 Greensmaster 3150...
  • Page 53: Steering Circuit Problems

    Hydraulic flow to steering control valve is low (traction charge and only) is insufficient. lift circuits affected as well). Implement relief valve is leaking or damaged (see Implement Relief Valve Pressure Test in the Testing section of this chapter). Greensmaster 3150 Page 4 - - 25 Hydraulic System...
  • Page 54: Testing

    Wheel Motor Efficiency Test ly removed within a few hours by a doctor famil- Piston (Traction) Pump Flow Test iar with this type of injury. Gangrene may result from such an injury. Hydraulic System Page 4 - - 26 Greensmaster 3150...
  • Page 55 Lower Cutting Units Relief Valve (R2) Pressure Test Reel Motor Case Drain Flow Test Implement Relief Valve Pressure Test Gear Pump (Front Section) Flow Test Gear Pump (Rear Section) Flow Test Steering Valve Test Greensmaster 3150 Page 4 - - 27 Hydraulic System...
  • Page 56: Charge Relief Valve Pressure Test

    Charge Relief Valve Pressure Test (Using Pressure Gauge) PRESSURE GAUGE Hydraulic System Page 4 - - 28 Greensmaster 3150...
  • Page 57 Move functional control lever to the trans- port position. Greensmaster 3150 Page 4 - - 29 Hydraulic System...
  • Page 58: Wheel Motor Efficiency Test

    5. If machine has 3 wheel drive, block up the rear wheel 2. Park machine on a level surface with the cutting units off the ground to allow flow through the rear wheel motor. lowered and off. Make sure engine is off. Hydraulic System Page 4 - - 30 Greensmaster 3150...
  • Page 59 16.Test second front wheel motor. Reconnect hydraulic lines to untested front wheel motor. Disconnect and cap hydraulic lines to previously tested front wheel motor. Complete steps 10 to 15 for the second front wheel mo- tor. Greensmaster 3150 Page 4 - - 31 Hydraulic System...
  • Page 60 2. Park machine on a level surface with the cutting units (refer to Traction Unit Operator’s manual). lowered and off. Make sure engine is off. Make sure the hydraulic reservoir is full. Hydraulic System Page 4 - - 32 Greensmaster 3150...
  • Page 61 14.5 GPM (54.9 LPM). 1. Piston pump 3. Hydraulic tube 2. Upper fitting 4. Hydraulic hose 12.Release traction pedal, open control valve on tester and turn off engine. Greensmaster 3150 Page 4 - - 33 Hydraulic System...
  • Page 62: Gear Pump (Rear Section) Flow Test

    Gear Pump (Rear Section) Flow Test (Using Tester with Flowmeter and Pressure Gauge) TESTER Hydraulic System Page 4 - - 34 Greensmaster 3150...
  • Page 63 8. Watch flow and pressure gauge carefully while slow- Figure 22 ly closing the flow control valve on the tester until the 1. Gear pump 2. Rear section fitting pressure gauge reads 800 PSI (55 bar). Greensmaster 3150 Page 4 - - 35 Hydraulic System...
  • Page 64: Implement Relief Valve Pressure Test

    Implement Relief Valve Pressure Test (Using Tester with Flowmeter and Pressure Gauge) TESTER Hydraulic System Page 4 - - 36 Greensmaster 3150...
  • Page 65 NOTE: The implement relief valve is in series with Figure 23 charge relief valve. Charge relief pressure will affect the 1. Gear pump 2. Rear section fitting implement relief pressure. Greensmaster 3150 Page 4 - - 37 Hydraulic System...
  • Page 66: Lower Cutting Units Relief Valve (R2) Pressure Test (Using Tester With Flowmeter And

    Lower Cutting Units Relief Valve (R2) Pressure Test (Using Tester with Flowmeter and Pressure Gauge) TESTER Hydraulic System Page 4 - - 38 Greensmaster 3150...
  • Page 67 400 PSI (28 bar) higher than charge relief pressure (e.g. if charge relief valve pressure is 100 PSI (7 bar), the lower relief valve pressure should be approximately 500 PSI (35 bar)). Greensmaster 3150 Page 4 - - 39 Hydraulic System...
  • Page 68: Gear Pump (Front Section) Flow Test (Using Tester With Flowmeter And Pressure

    Gear Pump (Front Section) Flow Test (Using Tester with Flowmeter and Pressure Gauge) TESTER Hydraulic System Page 4 - - 40 Greensmaster 3150...
  • Page 69 In this test, the flow tester is positioned be- Figure 26 fore the circuit relief valve. Gear pump damage can occur if the oil flow is fully restricted. 1. Gear pump 2. Front section fitting Greensmaster 3150 Page 4 - - 41 Hydraulic System...
  • Page 70: Mow Circuit Relief Valve (S1R1) Pressure Test (Using Tester With Flowmeter And

    Mow Circuit Relief Valve (S1R1) Pressure Test (Using Tester with Flowmeter and Pressure Gauge) TESTER Hydraulic System Page 4 - - 42 Greensmaster 3150...
  • Page 71 Record test results. 10.After recording mow circuit relief pressure, disen- gage cutting units. Open control valve on tester and shut off engine. A. If relief valve pressure is correct, go to step 11. Greensmaster 3150 Page 4 - - 43 Hydraulic System...
  • Page 72: Reel Motor Case Drain Flow Test

    PLUG MEASURING Center CONTAINER Reel (#1) Left Front Reel (#2) CASE DRAIN FLOW TEST FOR RIGHT FRONT REEL MOTOR SHOWN FROM MANIFOLD PORT MA TO MANIFOLD TO HYDRAULIC PORT MB RESERVOIR Hydraulic System Page 4 - - 44 Greensmaster 3150...
  • Page 73 While watching pressure gauge, slowly close flow control valve on the tester until a pressure of 1000 PSI (69 bar) is obtained. Figure 30 Greensmaster 3150 Page 4 - - 45 Hydraulic System...
  • Page 74: Steering Control Valve Test

    A. The steering wheel must go back immediately to the neutral position. A. There should be no shaking or vibration in the steering wheel or rear wheel. B. The steering wheel should not continue to turn. Hydraulic System Page 4 - - 46 Greensmaster 3150...
  • Page 75 7. If steering problem exists and steering cylinder tested acceptably, steering control valve requires ser- vice (see Steering Control Valve and Steering Control Valve Service in the Service and Repairs section of this chapter). Greensmaster 3150 Page 4 - - 47 Hydraulic System...
  • Page 76 This page is intentionally blank. Hydraulic System Page 4 - - 48 Greensmaster 3150...
  • Page 77: Adjustments

    1/8 turn on the socket will make a measurable change in relief pressure. 5. Install and tighten cap on relief valve. 6. Recheck relief pressure and readjust as needed. ADJUSTMENT HEX SOCKET Figure 33 Greensmaster 3150 Page 4 - - 49 Hydraulic System...
  • Page 78: Service And Repairs

    5. Note the position of hydraulic fittings (especially el- bow fittings) on hydraulic components before removal. Mark parts if necessary to make sure they will be aligned properly when reinstalling hydraulic hoses and tubes. Hydraulic System Page 4 - - 50 Greensmaster 3150...
  • Page 79: Flush Hydraulic System

    Traction Unit Operator’s Manual. Other fluids could cause system damage. 6. Reconnect all hydraulic hoses and lines that were disconnected prior to draining. Fill hydraulic reservoir. Figure 34 Greensmaster 3150 Page 4 - - 51 Hydraulic System...
  • Page 80: Filtering Closed--Loop Traction Circuit

    To effectively remove contamination from through the traction circuit and high flow filter. Keep trac- closed--loop traction circuit, use of the Toro high flow hy- tion circuit engaged for five (5) minutes while gradually draulic filter and hydraulic hose kits are recommended increasing both forward pressure on traction pedal and (see Special Tools in this chapter).
  • Page 81: Hydraulic System Start--Up

    The charge pump should pick up oil and fill the hydraulic system. If there is no indication of fill in thirty (30) seconds, stop the engine and determine the cause. Greensmaster 3150 Page 4 - - 53 Hydraulic System...
  • Page 82: Gear Pump

    3. Hydraulic fitting 9. O- -ring 15. Hydraulic hose 4. Hydraulic fitting 10. Hydraulic hose 16. Hose connector 5. O- -ring 11. O- -ring 17. O- -ring 6. O- -ring 12. Piston pump Hydraulic System Page 4 - - 54 Greensmaster 3150...
  • Page 83 2. Lubricate and place new O--ring (item 11) on the gear pump. 1. Piston pump case drain 2. Gear pump suction port 3. Position gear pump to the piston pump so that the pump inlet is facing up. Greensmaster 3150 Page 4 - - 55 Hydraulic System...
  • Page 84: Gear Pump Service

    Also, use a vise with soft jaws. pump assembly. 3. Secure the front cover of the pump in a vise with soft 5. Remove pump from vise and remove fasteners. jaws with the drive shaft pointing down. Hydraulic System Page 4 - - 56 Greensmaster 3150...
  • Page 85 33 ft- -lb (45 N- -m). 8. Clean all parts. Check all components for burrs, scoring, nicks and other damage. 9. Replace the entire pump assembly if any pump com- ponents are excessively worn or scored. Greensmaster 3150 Page 4 - - 57 Hydraulic System...
  • Page 86 11. Neutral arm 24. Cap screw 37. Piston pump assembly 12. Thrust washer 25. Flat washer (2 used) 38. Cap screw (2 used) 13. Traction stud 26. Dampener hose 39. Key Hydraulic System Page 4 - - 58 Greensmaster 3150...
  • Page 87 2. After traction neutral assembly has been installed, make sure that the transmission is adjusted for the neu- tral position so that the machine does not move or creep when the traction pedal is in neutral. Greensmaster 3150 Page 4 - - 59 Hydraulic System...
  • Page 88: Piston (Traction) Pump

    See Pis- ton (Traction) Pump Neutral Assembly in this section for information regarding servicing the neutral assembly. Hydraulic System Page 4 - - 60 Greensmaster 3150...
  • Page 89 Support the pump assembly when removing its supporting fasteners to prevent it from falling 1. Piston pump case drain port and causing personal injury. 2. Gear pump suction port 10.Support pump assembly to prevent it from falling. Greensmaster 3150 Page 4 - - 61 Hydraulic System...
  • Page 90 Adjust Transmission for Neutral in the Traction Unit Owner’s Manual. 5. Inspect threads and sealing surfaces of hydraulic fit- tings and hydraulic hose connectors. Replace any dam- aged or worn fittings or connectors. Hydraulic System Page 4 - - 62 Greensmaster 3150...
  • Page 91 This page is intentionally blank. Greensmaster 3150 Page 4 - - 63 Hydraulic System...
  • Page 92: Piston (Traction) Pump Service

    25. Cover plate 39. Bearing cup 12. Gasket 26. Swash plate insert 40. Shuttle relief valve with O- -ring 13. Valve plate 27. Shaft seal 41. Reverse relief valve 14. Bearing 28. Washer Hydraulic System Page 4 - - 64 Greensmaster 3150...
  • Page 93 Figure 47 1. Back plate 5. Poppet 2. Charge relief valve 6. Spring 3. O- -ring 7. Washer 4. Housing 8. Retaining ring Greensmaster 3150 Page 4 - - 65 Hydraulic System...
  • Page 94: Piston Pump Crush Ring Replacement

    Duty Piston Pump, Repair Information, Model Information, Model 70160 Variable Displacement Piston 70160 Variable Displacement Piston Pump at the end of Pump at the end of this chapter). this chapter). Hydraulic System Page 4 - - 66 Greensmaster 3150...
  • Page 95 This page is intentionally blank. Greensmaster 3150 Page 4 - - 67 Hydraulic System...
  • Page 96: Front Wheel Motors

    7. Drive stud (4 per hub) 16. Hydraulic hose 25. Clevis pin 8. Brake assembly 17. 45 Hydraulic fitting (2 per motor) 26. Swivel clevis 9. Brake cam 18. O- -ring 27. Cotter pin Hydraulic System Page 4 - - 68 Greensmaster 3150...
  • Page 97 7. Check oil level in hydraulic reservoir and add correct oil if necessary. 8. Follow Hydraulic System Start--up procedures (see Hydraulic System Start--up in this section). Greensmaster 3150 Page 4 - - 69 Hydraulic System...
  • Page 98: Rear Wheel Motor (Optional 3Wd)

    (item 14) on machines equipped with 3WD, see Rear Wheel (Optional 3WD) and Rear Wheel Hub and Motor Assembly (Optional 3WD) in the Service and Repairs section of Chapter 6 -- Chassis. Hydraulic System Page 4 - - 70 Greensmaster 3150...
  • Page 99 This page is intentionally blank. Greensmaster 3150 Page 4 - - 71 Hydraulic System...
  • Page 100: Wheel Motor Service

    24. End cover NOTE: For repair of the wheel motors, see the Parker Torqmotor Service Procedure (TC, TB, TE, TJ, TF, TG, TH and TL Series) at the end of this chapter. Hydraulic System Page 4 - - 72 Greensmaster 3150...
  • Page 101 This page is intentionally blank. Greensmaster 3150 Page 4 - - 73 Hydraulic System...
  • Page 102: Cutting Reel Motors

    34. Hydraulic tube 10. Hydraulic hose 23. Cap screw 35. Washer 11. Hydraulic hose 24. Flat washer 36. Bulkhead nut 12. Hydraulic hose 25. Flange nut 37. Bulkhead tee fitting 13. O- -ring Hydraulic System Page 4 - - 74 Greensmaster 3150...
  • Page 103 8. Hydraulic fitting 4. Install the flange head screws for the reel drive motor into the cutting unit side plate and leave approximately 1/2 inch (13 mm) of threads exposed on each screw. Greensmaster 3150 Page 4 - - 75 Hydraulic System...
  • Page 104 3. Hydraulic fitting 7. O- -ring ponents. 4. O- -ring 8. Hydraulic fitting 9. Check oil level in hydraulic reservoir and add correct oil if necessary. Hydraulic System Page 4 - - 76 Greensmaster 3150...
  • Page 105 This page is intentionally blank. Greensmaster 3150 Page 4 - - 77 Hydraulic System...
  • Page 106: Cutting Reel Motor Service

    2. Use a marker or scribe to make a diagonal mark across the front flange, body and rear cover for reas- sembly purposes (Fig. 58). Figure 58 Hydraulic System Page 4 - - 78 Greensmaster 3150...
  • Page 107 Use eye protection such as goggles when using compressed air. 2. Clean all motor components with solvent. Dry all parts with compressed air. Figure 61 1. Drive gear 3. Bearing block 2. Idler gear Greensmaster 3150 Page 4 - - 79 Hydraulic System...
  • Page 108 Follow by carefully plac- and repeat assembly process. ing the back--up rings into the grooves. 14.Remove motor from vise. 4. Install new O--rings to the body. Hydraulic System Page 4 - - 80 Greensmaster 3150...
  • Page 109 This page is intentionally blank. Greensmaster 3150 Page 4 - - 81 Hydraulic System...
  • Page 110: Front Lift Cylinders

    19. Hydraulic hose 5. Hydraulic hose 13. Spacer 20. Hinge pin 6. Cap screw 14. Hydraulic cylinder 21. RH torsion spring 7. Washer 15. Hydraulic hose 22. Hydraulic hose 8. Pivot pin Hydraulic System Page 4 - - 82 Greensmaster 3150...
  • Page 111 C. Remove hydraulic cylinder from the frame. 6. If necessary, remove hydraulic fittings from lift cylin- der. NOTE: See Lift Cylinder Service in this section for in- formation on lift cylinder service. Greensmaster 3150 Page 4 - - 83 Hydraulic System...
  • Page 112: Center Lift Cylinder

    13. Cotter pin 3. O- -ring 9. Lock nut 14. Clevis pin 4. O- -ring 10. Lift arm 15. Grease fitting 5. Hydraulic hose 11. Hydraulic cylinder 16. Hydraulic hose 6. Cap screw Hydraulic System Page 4 - - 84 Greensmaster 3150...
  • Page 113 45 hydraulic fitting for assembly pur- poses. Remove hydraulic fittings from lift cylinder. NOTE: See Lift Cylinder Service in this section for in- formation on lift cylinder service. Greensmaster 3150 Page 4 - - 85 Hydraulic System...
  • Page 114: Lift Cylinder Service

    11. Retaining ring 2. Wear ring 7. Seal 12. Piston 3. Seal with loader 8. Wiper 13. Lock nut 4. O- -ring 9. Head 14. Barrel 5. Back- -up ring 10. Rod Hydraulic System Page 4 - - 86 Greensmaster 3150...
  • Page 115 (deep scratches, out--of--round, etc.). Inspect shaft, head and piston for evidence of excessive scoring, pit- ting or wear. Replace entire cylinder if internal compo- nents are found to be worn or damaged. Greensmaster 3150 Page 4 - - 87 Hydraulic System...
  • Page 116: Hydraulic Manifold

    P1 is the gear pump con- nection port (see Hydraulic Schematic to identify the function of the hydraulic lines and cartridge valves at each port location). Hydraulic System Page 4 - - 88 Greensmaster 3150...
  • Page 117 Manifold damage is possible if the orifice is cocked in the port. 6. If necessary, remove hydraulic fittings and O--rings from the manifold. Greensmaster 3150 Page 4 - - 89 Hydraulic System...
  • Page 118: Hydraulic Manifold Service

    8. Plug (Zero Leak #8) (3 used) 18. Relief cartridge valve (R2) 28. Hydraulic fitting 9. Plug (SAE #4) (2 used) 19. Logic control cartridge valve (OR1) 29. Nut 10. Rotary cartridge valve (FC1) 20. Ball Hydraulic System Page 4 - - 90 Greensmaster 3150...
  • Page 119 B. If valve sealing surfaces appear pitted or dam- aged, the hydraulic system may be overheating or there may be water in the system. Greensmaster 3150 Page 4 - - 91 Hydraulic System...
  • Page 120 5. Bushing 11. Flow Control Valve erly on the cartridge valve for proper operation and 6. Set Screw (2 used) sealing. Hydraulic System Page 4 - - 92 Greensmaster 3150...
  • Page 121: Mow/Backlap Spool

    F. Place ball and dowel pin in backlap switch man- ifold port. Install new O--ring onto backlap switch. Thread backlap switch into port and torque 20 ft- -lb (27 N- -m). Greensmaster 3150 Page 4 - - 93 Hydraulic System...
  • Page 122: Steering Control Valve

    19. Straight hydraulic fitting (2 used) 30. Knob 9. Hex nut 20. O- -ring 31. Lock nut (2 used) 10. Screw 21. O- -ring 32. Hair pin 11. Steering wheel cover 22. Steering valve Hydraulic System Page 4 - - 94 Greensmaster 3150...
  • Page 123 10.If necessary, remove hydraulic fittings and O--rings from steering control valve. Discard all removed O-- Figure 71 rings. 1. T port 4. P port 2. R port 5. L port 3. E/Ls port Greensmaster 3150 Page 4 - - 95 Hydraulic System...
  • Page 124: Steering Control Valve Service

    10. Shaft seal 20. Outer gearwheel NOTE: For service of the steering control valve shown in Figure 72, see the Sauer/Danfoss Steering Unit Type OSPM Service Manual at the end of this chapter. Hydraulic System Page 4 - - 96 Greensmaster 3150...
  • Page 125 This page is intentionally blank. Greensmaster 3150 Page 4 - - 97 Hydraulic System...
  • Page 126: Steering Cylinder

    32. Lock nut (3 used) 10. Dust seal 22. Grease fitting 33. Motor adapter plate 11. Lug nut (4 used) 23. Drive stud (4 used) 34. Grease fitting 12. Wheel assembly Hydraulic System Page 4 - - 98 Greensmaster 3150...
  • Page 127 (Fig. 74). Record measured distance. Loosen jam nut and then remove rod end and jam nut from cylinder rod. MEASURE LENGTH FOR ASSEMBLY PURPOSES Figure 74 Greensmaster 3150 Page 4 - - 99 Hydraulic System...
  • Page 128: Steering Cylinder Service

    O--ring (item 8) or retain- ing ring (item 14) on the inside of the piston. If leakage or damage exists at the piston O--ring, steering cylinder replacement will be necessary. Hydraulic System Page 4 - - 100 Greensmaster 3150...
  • Page 129 7. Carefully inspect internal surface of barrel for dam- age (deep scratches, out--of--round, etc). Inspect rod, both heads and piston for evidence of excessive scor- ing, pitting or wear. Replace entire steering cylinder if in- ternal components are damaged. Greensmaster 3150 Page 4 - - 101 Hydraulic System...
  • Page 130: Leak Detector

    31. 90 barb fitting (2 used) 11. Short spacer (2 used) NOTE: See Turf Guardiant Leak Detector System in Chapter 5 -- Electrical System for leak detector opera- tion information. Hydraulic System Page 4 - - 102 Greensmaster 3150...
  • Page 131 B. Worn or leaking hydraulic hoses. Replace if nec- C. If fittings were removed from manifold, torque fit- essary. tings from 40 to 50 ft- -lb (55 to 67 N- -m). C. Visibly worn or damaged parts. Greensmaster 3150 Page 4 - - 103 Hydraulic System...
  • Page 132 B. Install four (4) cap screws (items 14 and 17), flat washers (item 13), neoprene washers (item 12) and spacers (items 11 and 18). C. Torque cap screws from 30 to 60 in- -lb (3.4 to 6.7 N- -m). Hydraulic System Page 4 - - 104 Greensmaster 3150...
  • Page 133 This page is intentionally blank. Greensmaster 3150 Page 4 - - 105 Hydraulic System...
  • Page 134: Hydraulic Reservoir

    12. Neoprene washer (4 used) 26. Tank valve hose 40. Hose clamp 13. Flat washer (2 used) 27. Hose clamp 41. Flange bushing (3 used) 14. Cap screw (2 used) 28. Barbed fitting Hydraulic System Page 4 - - 106 Greensmaster 3150...
  • Page 135 (Fig. 81). Torque sensor nut from 110 to 140 in- -lb (12.5 to 15.8 N- -m). Figure 81 1. Oil level sensor 2. Sensor arrow Greensmaster 3150 Page 4 - - 107 Hydraulic System...
  • Page 136 This page is intentionally blank. Hydraulic System Page 4 - - 108 Greensmaster 3150...
  • Page 137: Electrical System Quick Checks 5

    Safety Relays ......Greensmaster 3150 Page 5 - - 1 Electrical System...
  • Page 138: General Information

    Greensmaster 3150. Refer to that pub- lication for additional information when servicing the machine. Electrical Drawings The electrical schematic and other electrical drawings for the Greensmaster 3150 are located in Chapter 9 -- Foldout Drawings. Electrical System Page 5 - - 2 Greensmaster 3150...
  • Page 139: Special Tools

    The multimeter can test electrical components and cir- cuits for current, resistance or voltage. Obtain this tool locally. NOTE: Toro recommends the use of a DIGITAL Volt-- Ohm--Amp multimeter when testing electrical circuits. The high impedance (internal resistance) of a digital me- ter in the voltage mode will make sure that excess cur- rent is not allowed through the meter.
  • Page 140 Connectors should be thoroughly packed with lubricant for effective results. Toro Part Number: 107- -0342 Figure 4 Battery Hydrometer Use the Battery Hydrometer when measuring specific gravity of battery electrolyte.
  • Page 141: Turf Guardian Leak Detector System Operation

    5 oz (148 ml) of hydraulic fluid will (off) leak before the float closes the alarm circuit and acti- SOLENOID vates the alarm. VALVE (closed) MAIN HYDRAULIC TANK Figure 8 Greensmaster 3150 Page 5 - - 5 Electrical System...
  • Page 142: Troubleshooting

    Start safety relay (K2) is faulty. Neutral switch is out of adjustment or faulty. Starter solenoid fusible link is faulty. Ignition switch is faulty. Starter solenoid is faulty. Fuse block is faulty. Battery is faulty. Electrical System Page 5 - - 6 Greensmaster 3150...
  • Page 143 Engine fuel solenoid is faulty. Engine cranks (but should not) with the functional Neutral switch is out of adjustment, faulty or short control lever in the MOW or TRANSPORT position. circuited. Greensmaster 3150 Page 5 - - 7 Electrical System...
  • Page 144: General Run And Transport Problems

    Wiring to the run circuits components are faulty or disconnected (see Electrical Schematic and Circuit Diagrams in Chapter 9 -- Foldout Drawings). Engine or fuel system is malfunctioning (see Chapter 3 -- Engine). Electrical System Page 5 - - 8 Greensmaster 3150...
  • Page 145: Cutting Unit Operating Problems

    Fuse block or fuse is faulty. Diode D3 is open. Raise switch is faulty. Raise relay (K6) is faulty. Solenoid coil S3 and/or S2 is faulty. A hydraulic problem exists (see Chapter 4 -- Hydraulic System). Greensmaster 3150 Page 5 - - 9 Electrical System...
  • Page 146 Raise switch is faulty. Lower switch is faulty. Joystick relay (K3) is faulty. Lower relay (K5) is faulty. 6 second delay timer is faulty. Solenoid coil S2 or S4 is faulty. Electrical System Page 5 - - 10 Greensmaster 3150...
  • Page 147: Electrical System Quick Checks

    = 12.95 v NOTE: Depending upon the condition of the battery Difference = +0.65 v charge and battery temperature, the battery voltage will increase at different rates as the battery charges. Greensmaster 3150 Page 5 - - 11 Electrical System...
  • Page 148: Component Testing

    3. The 10 amp fuse (F3) supplies power to the engine run circuits and also to the hydraulic solenoid coils. 4. The 10 amp fuse (F4) supplies power to leak detec- tor solenoid and the cutting unit control circuits. Figure 10 Electrical System Page 5 - - 12 Greensmaster 3150...
  • Page 149: Hour Meter

    6. Press directly onto the seat switch through the seat cushion. There should be continuity as the seat cushion approaches the bottom of its travel. 7. Connect switch electrical connector. 8. Secure seat to support assembly with removed fas- teners. Greensmaster 3150 Page 5 - - 13 Electrical System...
  • Page 150: Safety Relays

    Safety Relays Several safety relays are used on Greensmaster 3150 3. Disconnect wire harness connector from relay that is machines. The safety relays are identical, five (5) termi- to be tested. If desired, remove relay from machine for nal relays that are used for circuit control.
  • Page 151: Neutral And Mow Switches

    (See Verify In- terlock System Operation in the Service and Repairs section of this chapter). Readjust switch or actuator if necessary. 10.Install console to right side of operator seat. Greensmaster 3150 Page 5 - - 15 Electrical System...
  • Page 152: Parking Brake Sensor

    (open) across the sensor terminals. 5. Release the parking brake. There should be continu- ity (closed) across the sensor terminals. 6. Connect sensor electrical connector. Reset the park- ing brake. Electrical System Page 5 - - 16 Greensmaster 3150...
  • Page 153: Joystick Raise And Lower Switches

    (green/black and gray/black wires). Figure 18 4. After testing, connect the harness connectors to the 1. Common terminal 3. NC terminal joystick switches and reinstall the plastic cover. 2. NO terminal 4. Switch lever Greensmaster 3150 Page 5 - - 17 Electrical System...
  • Page 154: Lower Reels Time Delay

    After six (6) seconds, there should be no voltage across the load. 4. After testing is complete, disconnect timer from 12VDC source and test load. LOAD 5. Lower operator seat. TIMING RESISTOR Figure 20 Electrical System Page 5 - - 18 Greensmaster 3150...
  • Page 155: Starter Solenoid

    Starter Solenoid The starter solenoid used on the Greensmaster 3150 al- lows current flow from the battery to the engine starter motor when energized. The starter solenoid is attached to the rear frame in front of the battery (Fig. 21).
  • Page 156: Solenoid Valve Coils

    The manifold S2 and S4 coils are identical. 4. After coil testing is completed, connect wire harness electrical connector to the solenoid valve coil. 5. Secure all machine components that were removed to access hydraulic manifold. Electrical System Page 5 - - 20 Greensmaster 3150...
  • Page 157: Backlap Switch

    (see Electrical Schematic and Wire Harness Drawings in Chapter 9 -- Foldout Drawings). 8. After testing is completed, connect wire harness electrical connector to the backlap switch. Lower opera- tor seat. Greensmaster 3150 Page 5 - - 21 Electrical System...
  • Page 158: Diodes

    The diodes are used for circuit protection from in- D1--B ductive voltage spikes and for safety circuit logic. Apply dielectric grease (Toro part number 107--0342) to circuit board contacts whenever the circuit board is installed into the wire harness.
  • Page 159: Fusible Links

    Fusible Links The electrical system on Greensmaster 3150 machines Testing includes two (2) fusible links for machine circuit protec- Make sure that ignition switch is OFF. Disconnect nega- tion. tive (--) battery cable from battery terminal and then dis- One of these fusible links is included in the main wire connect positive (+) cable from battery (see Battery harness.
  • Page 160: Leak Detector Test/Light Switch

    7. After testing is complete, connect machine wire har- LOWER 2 + 3 5 + 6 ness connector to leak detector test/light switch. Secure control panel shield to machine with removed fasteners. Figure 30 Electrical System Page 5 - - 24 Greensmaster 3150...
  • Page 161: Leak Detector Alarm And Delay Timer

    2. Turn ignition switch to the RUN position (do not start the engine), then move leak detector test switch rear- ward and hold. After a one (1) second time delay, the alarm should sound. Figure 31 1. Alarm 2. Delay timer Greensmaster 3150 Page 5 - - 25 Electrical System...
  • Page 162: Leak Detector Float Sensor

    110 to 140 in- -lb (12.5 to 15.8 N- -m). ALARM (on) 4. After testing, make sure that hydraulic oil level in res- ervoir is correct. Figure 33 Figure 34 1. Oil level sensor 2. Sensor arrow Electrical System Page 5 - - 26 Greensmaster 3150...
  • Page 163: Leak Detector Solenoid Valve

    Use a multimeter to make sure that the solenoid valve wire harness connector has 12 volts present. Figure 35 1. Main hydraulic tank 3. Valve spool 2. Valve body 4. Solenoid Greensmaster 3150 Page 5 - - 27 Electrical System...
  • Page 164: Service And Repairs

    If the engine stops, the interlock system is operating cor- traction pedal. If the pedal does not depress, the inter- rectly. Correct problem if not operating properly. lock system is operating correctly. Correct problem if not operating properly. Electrical System Page 5 - - 28 Greensmaster 3150...
  • Page 165: Battery Care

    (see Battery Service in this section). in this section). 2. Either store battery on a shelf or on the machine. Leave cables disconnected if the battery is stored on the machine. Greensmaster 3150 Page 5 - - 29 Electrical System...
  • Page 166: Battery Service

    3. Positive (+) cable 9. O- -ring (2 used) 4. Hold down rod 10. Battery tray 5. Wing nut (2 used) 11. Drain tube 6. Battery post (2 used) Electrical System Page 5 - - 30 Greensmaster 3150...
  • Page 167 I. If the test voltage is below the minimum, replace be met, replace the battery. the battery. If the test voltage is at or above the mini- mum, return the battery to service. Greensmaster 3150 Page 5 - - 31 Electrical System...
  • Page 168 11.5 hrs 17.3 hrs 23 hrs 6 amps 6 amps 6 amps 6 amps above 6 hrs 12 hrs 18 hrs 24 hrs 10 amps 10 amps 10 amps 10 amps Electrical System Page 5 - - 32 Greensmaster 3150...
  • Page 169: General Information 6

    ......Cutting Unit Pull Frame ..... Greensmaster 3150 Page 6 - - 1 Chassis...
  • Page 170: Specifications

    8 to 12 PSI (55 to 83 kPa) Rear tire pressure (18 x 9.50 x 8, 2 ply) 8 to 15 PSI (55 to 103 kPa) Wheel lug nut torque 70 to 90 ft--lb (95 to 122 N--m) Chassis Page 6 - - 2 Greensmaster 3150...
  • Page 171: General Information

    General Information Operator’s Manual The Operator’s Manual provides information regarding the operation, general maintenance and maintenance intervals for your Greensmaster 3150. Refer to that pub- lication for additional information when servicing the machine. Special Tools Order this special tool from your Toro Distributor.
  • Page 172: Service And Repairs

    (2) turns. Use hub puller (see Jacking Instructions in Chapter 1 -- Safety). Special Tools in this chapter) to loosen brake drum as- sembly from wheel motor. Chassis Page 6 - - 4 Greensmaster 3150...
  • Page 173 Figure 3 3. Position both brake shoes on the backing plate (Fig. 1. Return spring 3. Brake cam 3). Insert return springs into the holes of both brake 2. Brake shoe shoes. Greensmaster 3150 Page 6 - - 5 Chassis...
  • Page 174: Rear Wheel (2Wd)

    32. Lock nut (3 used) 9. Rod end 10. Dust seal 22. Grease fitting 33. Motor adapter plate 11. Lug nut (4 used) 23. Drive stud (4 used) 34. Grease fitting 12. Wheel assembly Chassis Page 6 - - 6 Greensmaster 3150...
  • Page 175 4. If removed, press new drive studs into the wheel hub fully to the shoulder of the stud flange. Greensmaster 3150 Page 6 - - 7 Chassis...
  • Page 176: Rear Wheel (Optional 3Wd)

    19. Hydraulic hose assembly 29. Grease fitting 9. Bearing flangette (lube) 20. Hydraulic tube assembly 30. Hydraulic hose assembly 10. Bearing 21. Washer (3 used) 31. Washer head screw (2 used) 11. Bearing flangette Chassis Page 6 - - 8 Greensmaster 3150...
  • Page 177 NOTE: If wheel hub and motor assembly need to be serviced, see Rear Wheel Hub and Motor Assembly (Optional 3WD) in this section. If castor fork removal is necessary, see Rear Castor Fork in this section. Greensmaster 3150 Page 6 - - 9 Chassis...
  • Page 178: Rear Wheel Hub And Motor Assembly (Optional 3Wd)

    2. Label hydraulic hoses that connect to rear wheel mo- tor for assembly purposes. Remove hose assemblies and O--rings from the hydraulic fittings on the hydraulic motor. Allow hoses to drain into a suitable container. Chassis Page 6 - - 10 Greensmaster 3150...
  • Page 179 General Information section of Chapter 4 -- Hydrau- lic System). 8. Install rear wheel hub and motor assembly to rear castor fork of machine (see Rear Wheel (Optional 3WD) in this section). Greensmaster 3150 Page 6 - - 11 Chassis...
  • Page 180: Rear Castor Fork

    32. Lock nut (3 used) 9. Rod end 10. Dust seal 22. Grease fitting 33. Motor adapter plate 11. Lug nut (4 used) 23. Drive stud (4 used) 34. Grease fitting 12. Wheel assembly Chassis Page 6 - - 12 Greensmaster 3150...
  • Page 181 11. Clean grease fitting (item 7) on frame pivot housing. Pump grease into pivot housing until grease is seen exit- ing at both ends of the housing. Wipe up excess grease. Greensmaster 3150 Page 6 - - 13 Chassis...
  • Page 182: Cutting Unit Pull Frame

    26. Roller shaft 40. Ball bearing (2 used) 41. Oil seal (2 used) 13. Grease fitting 27. Grease fitting 14. Grease fitting 28. Hydraulic fitting (2 used) 42. Flange bushing (2 per pull arm) Chassis Page 6 - - 14 Greensmaster 3150...
  • Page 183 (Fig. 14). Also, 1. Bushing 2. Grease groove ball bearing should be installed with seal toward end of roller. Figure 14 1. Roller 3. Ball bearing 2. Oil seal Greensmaster 3150 Page 6 - - 15 Chassis...
  • Page 184 This page is intentionally blank. Chassis Page 6 - - 16 Greensmaster 3150...
  • Page 185: Factors That Can Affect Cutting Performance . . 7

    ......Rear Roller Brush (Optional) ....Greensmaster 3150 Page 7 - - 1 DPA Cutting Units...
  • Page 186: Specifications

    Refer to Cutting Unit Operator’s Manual for available op- the front roller by two (2) vertical screws. Effective HOC tions for your Greensmaster 3150 DPA cutting unit. may vary depending on turf conditions, type of bedknife, roller type and installed attachments.
  • Page 187: General Information

    DPA cutting units on your Greensmaster 3150 machine. Additionally, if optional kits have been installed on the cutting units (e.g. rear roller brush), the installation instructions for the kit in- cludes set--up and operation information.
  • Page 188: Special Tools

    Cut adjustment Figure 3 Bedknife Screw Tool This screwdriver--type bit is made to fit Toro bedknife at- taching screws. Use this bit with a torque wrench to se- cure the bedknife to the bedbar. IMPORTANT: To prevent damage to the bedbar, DO NOT use an air or manual impact wrench with this tool.
  • Page 189 This tool should be used with the Toro Guide to Evaluation Reel Mower Performance and Using the TurfEvaluator (Toro part no. 97931SL).
  • Page 190: Factors That Can Affect Cutting Performance

    NOTE: For additional information regarding cutting unit cutting unit. It is important to remember that the lower troubleshooting, see Aftercut Appearance Trouble- the height--of--cut, the more critical these factors are. shooting Aid (Toro part no. 00076SL). Factor Possible Problem/Correction Tire pressure Check tire pressure of all traction unit tires.
  • Page 191 See Bedbar Removal and Installation in the Service and Repairs section of this chapter. Number of reel blades Use correct number of reel blades for clip frequency and optimum height--of--cut range. Greensmaster 3150 Page 7 - - 7 DPA Cutting Units...
  • Page 192 Cutting unit accessories A variety of cutting unit accessories are available that can be used to enhance aftercut appearance. Refer to Operator’s Manual for a listing of available accessories. Page 7 - - 8 Greensmaster 3150 DPA Cutting Units...
  • Page 193 This page is intentionally blank. Greensmaster 3150 Page 7 - - 9 DPA Cutting Units...
  • Page 194: Set Up And Adjustments

    See Cutting Unit Operator’s Manual for cutting unit ad- procedure needed to deliver optimum mowing perfor- justment procedures for your Greensmaster 3150 ma- mance. The precise adjustment possible with this de- chine.
  • Page 195: Leveling Rear Roller

    6. After tightening the side plate, recheck the rear roller. If necessary, loosen and adjust second side plate. 7. After leveling rear roller, complete cutting unit set--up and adjustment sequence. Greensmaster 3150 Page 7 - - 11 DPA Cutting Units...
  • Page 196: Service And Repairs

    2. Reel speed control one motor causes rotation in other motors. NOTE: Additional instructions and procedures on backlapping are available in the Toro General Service Training Book, Reel Mower Basics (part no. 09168SL). 1. Position the machine on a level surface, lower the cutting units, stop the engine and engage the parking brake.
  • Page 197 Adjust cutting unit reel to bedknife as needed. NOTE: If the backlap lever is not returned to the F (mow) position after backlapping, the cutting units will not function properly. Greensmaster 3150 Page 7 - - 13 DPA Cutting Units...
  • Page 198: Bedbar Assembly

    3. Tip the cutting unit to expose the bedknife. Support (item 16) from the cutting unit side plates. the rear of the cutting unit (see Supporting Cutting Unit when Servicing in the General Information section of this chapter). Page 7 - - 14 Greensmaster 3150 DPA Cutting Units...
  • Page 199 5. Position bedbar into cutting unit. Make sure that the 4. Plastic washer 8. Lock nut top of each bedbar arm is between washer (item 11) and adjuster screw flange (item 4). Greensmaster 3150 Page 7 - - 15 DPA Cutting Units...
  • Page 200: Bedbar Adjuster Service

    5. Flange bushing 9. Retaining ring 2. Compression spring 6. Cap screw 10. Bedbar adjuster screw 3. Lock nut 7. Detent 11. Washer 4. Bedbar adjuster shaft 8. Wave washer Page 7 - - 16 Greensmaster 3150 DPA Cutting Units...
  • Page 201 (item 3) onto adjuster screw. Tighten the lock nut on each bedbar adjuster assembly until the compression spring is fully compressed, then loosen lock nut 1/2 turn. 7. Adjust cutting unit (see Cutting Unit Operator’s Manual). Greensmaster 3150 Page 7 - - 17 DPA Cutting Units...
  • Page 202: Bedknife Replacement And Grinding

    Lightly oil bedbar surface before (Fig. 18). installing bedknife. 5. After installing bedknife to bedbar, grind bedknife. 2. Make sure that screw threads bedbar (5/16--18UNC--2A) are clean. If necessary, use tap to clean threads. Page 7 - - 18 Greensmaster 3150 DPA Cutting Units...
  • Page 203 Also, clean and dress grinding stone often during the grinding process. 10 12 1. Use Toro General Service Training Book, Reel Mow- Figure 18 er Basics (part no. 09168SL) and grinder manufactur- er’s instructions for bedknife grinding information.
  • Page 204: Reel Assembly Removal And Installation

    The RH side plate does not have to be removed from the nut) from the cutting unit. Refer to Reel Assembly Ser- frame when using the following procedure. vice later in this section for information on servicing the cutting reel assembly. Page 7 - - 20 Greensmaster 3150 DPA Cutting Units...
  • Page 205: Reel Assembly Removal

    10.Carefully slide the cutting reel assembly (with shaft. flocked seals, reel bearings and reel nuts) from the RH side plate. Greensmaster 3150 Page 7 - - 21 DPA Cutting Units...
  • Page 206 Brush in this section for information on rear roller brush. 10.Secure front and rear rollers to LH side plate (see Front Roller Installation and Rear Roller Installation in 14.Install cutting unit to the machine. this section). Page 7 - - 22 Greensmaster 3150 DPA Cutting Units...
  • Page 207 This page is intentionally blank. Greensmaster 3150 Page 7 - - 23 DPA Cutting Units...
  • Page 208: Reel Assembly Service

    (item 6) has a black finish and has notches on the head. The reel nut with right hand threads (item 5) has a zinc finish and does not have notches on the head. Page 7 - - 24 Greensmaster 3150 DPA Cutting Units...
  • Page 209 (see Reel Assembly Removal and Installation in this section). 4. Thoroughly fill spline area of reel nuts with grease. Greensmaster 3150 Page 7 - - 25 DPA Cutting Units...
  • Page 210: Preparing Reel For Grinding

    1. Follow reel grinder manufacturer’s instructions to Blade Land Width Range 0.030 to 0.050 in (0.8 to 1.2 mm) grind cutting reel to Toro specifications (see Reel Grind- ing Specifications chart to the right). Additional reel Service Limit - 0.010 in (0.25 mm)
  • Page 211 This page is intentionally blank. Greensmaster 3150 Page 7 - - 27 DPA Cutting Units...
  • Page 212: Front Roller

    4. HOC washer & nut (item 7). 5. Center front roller to the cutting reel and secure to HOC arms with cap screws (item 1). 6. Adjust cutting unit (see Cutting Unit Operator’s Manual). Page 7 - - 28 Greensmaster 3150 DPA Cutting Units...
  • Page 213: Rear Roller

    Install two (2) carriage screws and flange nuts to retain assem- bly in position but do not fully tighten flange nuts. Greensmaster 3150 Page 7 - - 29 DPA Cutting Units...
  • Page 214: Roller Service

    This will preserve the patch lock feature in the new lock nuts. Use the new nuts only after new bearings and Figure 31 seals have been installed. 1. Bearing lock nut 3. Bearing 2. Black assembly washer Page 7 - - 30 Greensmaster 3150 DPA Cutting Units...
  • Page 215 4. Seal nut(s). 12.Install bearing lock nut with V--ring onto each end of the roller shaft. Torque lock nuts from 25 to 30 ft- -lb (34 to 41 N- -m). Greensmaster 3150 Page 7 - - 31 DPA Cutting Units...
  • Page 216 (opposite from brush kit has detailed information regarding assembly the hydraulic cutting reel motor). and adjustment. Use those Instructions along with this Service Manual when servicing the rear roller brush. Page 7 - - 32 Greensmaster 3150 DPA Cutting Units...
  • Page 217 C. Tighten set screw in locking collar to secure the bearing assembly to the brush shaft. Greensmaster 3150 Page 7 - - 33 DPA Cutting Units...
  • Page 218 0.010” (0.25 mm) clearance to light contact with roller. If contact is incorrect, brush operation will be adversely affected. 8. Lubricate grease fittings on brush support and drive plate until grease is visible. Wipe up excess grease. Page 7 - - 34 Greensmaster 3150 DPA Cutting Units...
  • Page 219 ......Groomer Brush ......Greensmaster 3150 Page 8 - - 1 Groomer...
  • Page 220: Specifications

    Groomer brush can be installed in place of UP- -DOWN FEATURE: Allows grooming reel to be grooming reel. raised above the height/depth adjustment for no groom- ing reel action while cutting. Groomer Page 8 - - 2 Greensmaster 3150...
  • Page 221: General Information

    The Installation Instructions for the groomer provide in- formation regarding the operation, general mainte- nance procedures and maintenance intervals for the groomer assembly on your Greensmaster 3150 ma- chine. Refer to this publication for additional information when servicing the groomer assembly.
  • Page 222: Troubleshooting

    5. The height--of--cut. 11. Stress periods for turf (e.g. high temperatures, high humidity, unusually high traffic). 6. The grooming depth. 7. The type of grass on the green. Groomer Page 8 - - 4 Greensmaster 3150...
  • Page 223: Grooming Reel Mechanical Problems

    Grooming depth is not equal on Adjust depth if necessary. Check both ends of grooming reel. and adjust cutting unit set up (level bedknife to reel, level rear roller to reel, set height--of--cut, etc.). Greensmaster 3150 Page 8 - - 5 Groomer...
  • Page 224: Adjustments

    0.003 inch (0.08 mm). 5. Repeat step 4 on the opposite end of the groomer. Then, recheck setting on the first side of groomer. Height setting on both ends of groomer should be identi- cal. Groomer Page 8 - - 6 Greensmaster 3150...
  • Page 225: Service And Repairs

    (see Rear Roller Brush Installation in the Service and Repairs section of Chapter 7 -- DPA Cutting Units). Figure 3 1. Drive pulley 4. Driven pulley 2. Idler pulley 5. Groomer drive belt 3. Idler pulley nut Greensmaster 3150 Page 8 - - 7 Groomer...
  • Page 226: Grooming Reel

    (opposite from switch. the hydraulic cutting reel motor). 2. Remove the cutting unit from the machine and place cutting unit on a flat work area. Groomer Page 8 - - 8 Greensmaster 3150...
  • Page 227 (item 19) taking care to not get grease on belt surface of grooming shaft. Apply light coating of grease to O--ring. pulley. Slide driven pulley onto the grooming reel shaft taking care to not damage seal in drive plate. Greensmaster 3150 Page 8 - - 9 Groomer...
  • Page 228 30 seconds, stop machine and wipe excess groomer arm to cutting unit with plow bolt (item 22), HOC grease from groomer shaft and seals. washer (item 16) and HOC nut (item 21). Groomer Page 8 - - 10 Greensmaster 3150...
  • Page 229: Grooming Reel Service

    250 in- -lb (23 to 28 N- -m) so spacers are not free to CENTER BLADES ON SHAFT rotate. 5. Install grooming reel back onto cutting unit (see Grooming Reel Installation in this section). Figure 9 1. Lock nut 2. Grooming shaft Greensmaster 3150 Page 8 - - 11 Groomer...
  • Page 230: Grooming Reel Bearing Replacement

    RH groomer arm lift rod to support plate (Fig. 12). Re- 2. Remove front roller, grooming reel and drive plate move support plate from cutting unit. assembly from left side of cutting unit (see Grooming Reel Removal in this section). Groomer Page 8 - - 12 Greensmaster 3150...
  • Page 231 6. Support plate bearing groomer for 30 seconds, stop machine and wipe any ex- 3. Inner bearing 7. Drive plate cess grease from groomer shaft and seals. 4. Inner race 8. Support plate Greensmaster 3150 Page 8 - - 13 Groomer...
  • Page 232: Idler Assembly

    5. Drive plate assembly 9. Bearing (2 used) 2. Spacer 6. O- -ring 10. Retaining ring 3. Idler bracket 7. Retaining ring 11. Idler pulley 4. Spacer 8. Grease fitting 12. Lock nut Groomer Page 8 - - 14 Greensmaster 3150...
  • Page 233 3. Install drive pulley, drive belt and belt cover to left side of cutting unit (see Grooming Reel Installation in this section). 4. Check and adjust grooming reel height and mower height--of--cut settings. Greensmaster 3150 Page 8 - - 15 Groomer...
  • Page 234: Lift Arm Assembly

    9. Detent spring 15. Side plate (LH shown) 4. E- -ring 10. Spring washer 16. Lock nut 5. Groomer lift rod 11. Cap screw 17. Spring washer 6. Lock screw 12. Bushing 18. Bushing Groomer Page 8 - - 16 Greensmaster 3150...
  • Page 235 Figure 16 are the same on both sides 5. Check and adjust grooming reel height and mower of cutting unit. height--of--cut settings. NOTE: Grooved pin (item 3) is used to retain lock screw (item 6) to lift arm assembly. Greensmaster 3150 Page 8 - - 17 Groomer...
  • Page 236: Groomer Brush

    Figure 18 threaded portion on the outside of the brush (Fig. 18). Torque lock nuts from 20 to 25 in- -lb (2.3 to 2.8 N- -m). 1. J- -bolt 2. Lock nut Groomer Page 8 - - 18 Greensmaster 3150...
  • Page 237: Hydraulic Schematic

    ..... . Engine Wire Harness Drawing ....Greensmaster 3150 Page 9 - - 1 Foldout Drawings...
  • Page 238 This page is intentionally blank. Foldout Drawings Page 9 - - 2 Greensmaster 3150...
  • Page 239: Hydraulic Schematic

    LEAK OPTIONAL DETECTOR ENGINE RPM OIL COOLER GEAR 1.24 VOLUME 2850/1650 PUMP 3000 PSI 20.6 70 to 100 110 to 150 EXPANSION OPTIONAL TANK BOTTOM 3WD KIT PORT BREATHER SUCTION Greensmaster 3150 STRAINER Hydraulic Schematic Page 9 - - 3...
  • Page 240 (IN NEUTRAL) (NOT OCCUPIED) Greensmaster 3150 Electrical Schematic All relays and solenoids are shown as de- - energized. Page 9 - - 4...
  • Page 241: Crank Circuits

    (ENERGIZED) (IN NEUTRAL) (ENERGIZED) (ENERGIZED) (NOT OCCUPIED) (ENERGIZED) Greensmaster 3150 Crank Circuits Power Current Control Current Indication Current Page 9 - - 5...
  • Page 242: Run Circuits

    (NOT IN NEUTRAL) (OCCUPIED) (OFF POSITION) (ENERGIZED) Greensmaster 3150 Run Circuits Power Current Control Current Indication Current Page 9 - - 6...
  • Page 243: Raise Reels Circuits

    (NOT IN NEUTRAL) (OCCUPIED) (OFF POSITION) (ENERGIZED) (ENERGIZED) Greensmaster 3150 Raise Reels Circuits Power Current Control Current Indication Current Page 9 - - 7...
  • Page 244 (NOT IN NEUTRAL) (OCCUPIED) (OFF POSITION) (ENERGIZED) NOTE: TIME DELAY KEEPS THE LOWER RELAY ENERGIZED FOR SIX (6) SECONDS (ENERGIZED) (ENERGIZED) Greensmaster 3150 Lower Reels (6 Seconds) Circuits Power Current Control Current Indication Current Page 9 - - 8...
  • Page 245: Mow Circuits

    (OFF POSITION) (MOW POSITION) NOTE: DIODE D1- - C ALLOWS (ENERGIZED) CURRENT FLOW TO KEEP JOYSTICK RELAY ENERGIZED AFTER JOYSTICK IS RELEASED FROM LOWER (ENERGIZED) Greensmaster 3150 Mow Circuits Power Current Control Current Indication Current Page 9 - - 9...
  • Page 246: Backlap Circuits

    (NOT OCCUPIED) (ON POSITION) NOTE: DIODE D1- - C ALLOWS (ENERGIZED) CURRENT FLOW TO KEEP JOYSTICK RELAY ENERGIZED AFTER JOYSTICK IS RELEASED FROM LOWER (ENERGIZED) Greensmaster 3150 Backlap Circuits Power Current Control Current Indication Current Page 9 - - 10...
  • Page 247 This page is intentionally blank. Page 9 - - 11...
  • Page 248: Wire Harness Drawing

    SEAT WIRE HARNESS Greensmaster 3150 Wire Harness Drawing Page 9 - - 12...
  • Page 249: Wire Harness Diagram

    BLACK YELLOW WHITE/BLUE VIOLET PINK WHITE PINK ORANGE/BLACK ORANGE YELLOW YELLOW GREEN BLUE BLUE/BLACK WHITE BLUE YELLOW GRAY GRAY WHITE WHITE Greensmaster 3150 (TO ENGINE HARNESS) (TO SEAT HARNESS) (TO SEAT HARNESS) Wire Harness Diagram Page 9 - - 13...
  • Page 250: Engine Wire Harness Drawing

    YELLOW VIOLET WHITE FUSIBLE LINK BLACK Greensmaster 3150 Engine Wire Harness Drawing Page 9 - - 14...

Table of Contents