Napoleon NEFL32FH Installation And Operating Instructions Manual
Hide thumbs
Also See for NEFL32FH:
- Installation and operating instructions manual (52 pages) ,
- Installation and operation manual (60 pages) ,
- Service manual (30 pages)
Table of Contents
Advertisement
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE.
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS: CSA C22.2 No-46 / UL 1278
NEFL32FH, NEFL42FH, NEFL50FH,
NEFL60FH, NEFL72FH, NEFL100FH
SAFETY INFORMATION
WARNING
!
If the information in these instructions
are not followed exactly, a fi re may result
causing property damage, personal injury
or loss of life.
- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.
Phone (705)721-1212 • Fax (705)722-6031 • www.napoleonfi replaces.com •hearth@napoleonproducts.com
$10.00
INSTALLATION AND
OPERATING INSTRUCTIONS
ELECTRIC FIREPLACE
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
1.16E
W415-1542 / 08.26.15
EN
FR
PG
25
Advertisement
Table of Contents
Related Manuals for Napoleon NEFL32FH
Summary of Contents for Napoleon NEFL32FH
- Page 1 Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada / 103 Miller Drive, Crittenden, Kentucky, USA, 41030 Phone (705)721-1212 • Fax (705)722-6031 • www.napoleonfi replaces.com •hearth@napoleonproducts.com 1.16E...
-
Page 2: Table Of Contents
TABLE OF CONTENTS INTRODUCTION DIMENSIONS LISTING APPROVALS GENERAL INSTRUCTIONS UNPACKING AND TESTING APPLIANCE HARDWARE PARTS LIST (NEFL32FH) HARDWARE PARTS LIST (NEFL42/50FH) HARDWARE PARTS LIST (NEFL60/72FH) HARDWARE PARTS LIST (NEFL100FH) RATING PLATE INFORMATION LOCATING APPLIANCE GROUNDING APPLIANCE INSTALLATION MINIMUM CLEARANCE TO COMBUSTIBLES... -
Page 3: Introduction
1.0 INTRODUCTION WARNING • THIS APPLIANCE IS HOT WHEN OPERATED AND CAN CAUSE SEVERE BURNS IF CONTACTED. • Do not operate appliance before reading and understanding operating instructions. Failure to operate appliance according to operating instructions could cause fi re or injury. •... -
Page 4: En 1.1 Dimensions
NOTE: This appliance must be electrically wired and grounded in accordance with local codes or, in the absence of local codes, with National Electric Code ANSI/NFPA 70-latest edition in the United States or the Canadian Electric Code, CSA C22.1 in Canada. DIMENSIONS MODEL NUMBER NEFL32FH 32" 21 5/8" 12" 22 5/16"... -
Page 5: General Instructions
GENERAL INSTRUCTIONS WARNING READ THESE INSTRUCTIONS COMPLETELY BEFORE BEGINNING INSTALLATION. FAILURE TO FOLLOW THEM COULD CAUSE AN APPLIANCE MALFUNCTION RESULTING IN SERIOUS INJURY AND/OR PROPERTY DAMAGE. ALL ELECTRIC APPLIANCES HAVE HOT AND ARCING OR SPARKING PARTS INSIDE. DO NOT USE IT IN AREAS WHERE GASOLINE, PAINT OR FLAMMABLE LIQUIDS ARE PRESENT. -
Page 6: Hardware Parts List (Nefl32Fh)
HARDWARE PARTS LIST (NEFL32FH) HARDWARE PARTS LIST (NEFL42/50FH) W415-1542 / 08.26.15... -
Page 7: Hardware Parts List (Nefl60/72Fh)
HARDWARE PARTS LIST (NEFL60/72FH) HARDWARE PARTS LIST (NEFL100FH) W415-1542 / 08.26.15... -
Page 8: Rating Plate Information
BY WOLF S BY WOLF S PAR WOLF STEEL LTD. MADE IN CHINA FABRIQUE EN CHINE WOLF STEEL LTD. D. D. 24 NAPOLEON ROAD, ROAD, SERIAL NUMBER/NO. DE SERIE: NEFL BARRIE, ON, L4M 0G8 CANADA L4M 0G8 CANADA M 0G8 CANADA... -
Page 9: Locating Appliance
2.0 LOCATING APPLIANCE WARNING DUE TO HIGH TEMPERATURES, THIS ELECTRIC APPLIANCE SHOULD BE LOCATED OUT OF TRAFFIC. KEEP COMBUSTIBLE MATERIALS SUCH AS FURNITURE, PILLOWS, BEDDING, PAPERS, CLOTHES AND CURTAINS AT LEAST 36" FROM THE FRONT OF THE APPLIANCE. NEVER LOCATE THIS ELECTRIC APPLIANCE WHERE IT MAY FALL INTO A BATHTUB OR OTHER WATER CONTAINER. -
Page 10: Installation
3.0 INSTALLATION WARNING RISK OF FIRE! THE POWER CORD MUST NOT BE PINCHED AGAINST A SHARP EDGE. SECURE CORD TO AVOID TRIPPING OR SNAGGING TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK OR PERSONAL INJURY. DO NOT RUN CORD UNDER CARPETING. DO NOT COVER CORD WITH THROW RUGS, RUNNERS OR THE LIKE. ARRANGE CORD AWAY FROM TRAFFIC AREAS AND WHERE IT WILL NOT BE TRIPPED OVER. -
Page 11: Installing The Appliance Onto The Wall
INSTALLING THE APPLIANCE ONTO THE WALL Due to the many different materials used on different walls, it is highly BODY recommended that you consult your local builder before you install this GLASS FRONT appliance on the wall. Select a location that is not prone to moisture and is located at least 36"... -
Page 12: Minimum Clearance To Combustibles
Sides, back and top 0" 3.3.2 FRAMING Finishing Material JUNCTION (NON-LOAD BEARING) 5" 3 1/2" 127mm 89mm MODEL NO. NEFL32FH 21" (535mm) 27 13/16" (706mm) NEFL42FH 21" (535mm) 38" (965mm) NEFL50H 21" (535mm) 49 7/8" (1165mm) NEFL60H 21" (535mm) 45 7/8" (1165mm) NEFL72H 21"... -
Page 13: Recessing The Appliance Into The Wall
RECESSING THE APPLIANCE INTO THE WALL Due to the many different fi nish materials used on walls, it is highly recommended that you consult your local builder before you install this appliance in the wall. Select a location that is not prone to moisture and is located at least 36" (914mm) away from combustible materials such as curtain drapes, furniture, bedding, paper etc. -
Page 14: Installing The Appliance Into A Mantel
NOTE: The appliance tabs come bent. You must bend the tab fl at by hand when fully recessing the appliance into the wall, Figure 4. FIG. 4 3.4.1 INSTALLING THE APPLIANCE INTO A MANTEL Remove the glass front, refer to "FRONT GLASS REMOVAL " section for removal instructions. Install the rubber feet onto the bottom of the appliance for stability. -
Page 15: Rubber Feet Installation
3.4.2 RUBBER FEET INSTALLATION Place the appliance face down on a soft surface. Using a screw driver, remove the screws on the bottom of the appliance. Install the 4 rubber feet (6 rubber feet for NEFL60/72/100FH) onto the bottom of the appliance using the screws from Step B, see below. -
Page 16: Hard Wiring Installation
HARD WIRING INSTALLATION WARNING TURN OFF THE APPLIANCE COMPLETELY AND LET COOL BEFORE SERVICING. ONLY A QUALIFIED SERVICE PERSON SHOULD SERVICE AND REPAIR THIS ELECTRIC APPLIANCE. HARD WIRING CONNECTION If it is necessary to hard wire this appliance, a qualifi ed electrician must remove the cord connection, and wire the appliance directly to the house hold wiring. -
Page 17: Finishing
4.0 FINISHING WARNING POWER SUPPLY SERVICE MUST BE COMPLETED PRIOR TO FINISHING TO AVOID RECONSTRUCTION. HEAT VENTS AND AIR OPENINGS CANNOT BE COVERED IN ANY CIRCUMSTANCES. FRONT GLASS INSTALLATION WARNING BEFORE THE FRONT GLASS IS INSTALLED OR REMOVED UNPLUG THE APPLIANCE AND WAIT UNTIL APPLIANCE IS COOL TO THE TOUCH. -
Page 18: Front Glass Removal
FRONT GLASS REMOVAL FOR WALL MOUNT, PARTIAL RECESS AND MANTEL INSTALLED APPLIANCE ONLY: Remove the 2 screws from the top of the appliance, as shown below. Have two people, lift the glass up and away from the appliance, holding the glass vertical not fl at while carrying. -
Page 19: Operating Instructions
5.0 OPERATING INSTRUCTIONS WARNING WHILE THE APPLIANCE IS OPERATING DO NOT REMOVE THE GLASS PANEL. THIS WILL CAUSE THE REMOTE CONTROL AND TOUCH PANEL TO DISFUNCTION. Once the appliance has been plugged into a grounded electrical outlet, it is ready to operate. NOTE: Ensure the house circuit breakers for the power supply are turned on. -
Page 20: Maintenance
6.0 MAINTENANCE WARNING PREPARATION FOR MAINTENANCE ALWAYS DISCONNECT THE POWER AND ALLOW THE ELECTRIC APPLIANCE TO COOL BEFORE PERFORMING ANY CLEANING, MAINTENANCE OR RELOCATION OF THIS ELECTRIC APPLIANCE. TURN CONTROLS TO OFF AND REMOVE PLUG FROM OUTLET OR TURN OFF THE HOUSE CIRCUIT BREAKER TO ELECTRIC APPLIANCE RECEPTACLE. -
Page 21: Wiring Diagram
7.0 WIRING DIAGRAM WARNING TURN OFF THE APPLIANCE COMPLETELY AND LET COOL BEFORE SERVICING. ONLY A QUALIFIED SERVICE PERSON SHOULD SERVICE AND REPAIR THIS ELECTRIC APPLIANCE. W415-1542 / 08.26.15... - Page 22 W415-1542 / 08.26.15...
-
Page 23: Replacement Parts
Description of part RESULT IN PROPERTY DAMAGE OR • Finish PERSONAL INJURY. FOR FURTHER INFORMATION, CONTACT YOUR AUTHORIZED DEALER. 41.1 For after sales service, please call 1-866-820-8686 COMPONENTS REF. NEFL32FH NEFL42FH NEFL50FH NEFL60FH NEFL72FH NEFL100FH DESCRIPTION W300-0226 W300-0224 W300-0227 W300-0228... -
Page 24: Troubleshooting
9.0 TROUBLESHOOTING WARNING TURN OFF THE APPLIANCE COMPLETELY AND LET COOL BEFORE SERVICING. ONLY A QUALIFIED SERVICE PERSON SHOULD SERVICE AND REPAIR THIS ELECTRIC APPLIANCE. SYMPTOM PROBLEM TEST SOLUTION Dim or no fl ame / LED’s are burnt out Inspect the LED’s and replace them if necessary Ember bed is not glowing or dimming No warm air coming... -
Page 25: Warranty
NAPOLEON warrants its products against manufacturing defects to the original purchaser only. Registering your warranty is not necessary. Simply provide your proof of purchase along with the model and serial number to make a warranty claim. NAPOLEON reserves the right to have its representative inspect any product or part thereof prior to honouring any warranty claim. -
Page 26: Notes
11.0 NOTES 44.1 W415-1542 / 08.26.15... - Page 27 44.1 W415-1542 / 08.26.15...
- Page 28 napoleonproducts.com...